Vitamin D-Binding Protein Deficiency and Homozygous Deletion of the GC Gene.

A 58-year-old woman with debilitating ankylosing spondylitis who was born to consanguineous parents was found to have an apparent severe vitamin D deficiency that did not respond to supplementation. Liquid chromatography-tandem mass spectrometry showed the absence of circulating vitamin D-binding protein, and chromosomal microarray confirmed a homozygous deletion of the group-specific component (GC) gene that encodes the protein. Congenital absence of vitamin D-binding protein resulted in normocalcemia and a relatively mild disruption of bone metabolism, in this case complicated by severe autoimmune disease. (Funded by the National Institutes of Health and the University of Washington.).

Congenital hiatal hernia segregating with a duplication in 9q22.31q22.32 in two families.

Congenital hiatal hernia (HH) is a rare congenital defect and is often described on a sporadic basis, but familial cases have also been reported. The mechanism of development is not well understood, and to our knowledge no specific genetic factors have been implicated to date. We report on seven individuals from two families with 9q22 duplication, who have variably associated features including congenital HH in four individuals. One family had an 1.09 Mb 9q22 duplication, and the other family had an overlapping 2.73 Mb 9q22 duplication. We review the genes in this region and discuss BARX1 (BarH-like homeobox gene 1) as a gene of interest.

Atypical Prenatal Ultrasound Presentation and Neuropathological Findings in a Neonate With Alpha Thalassemia Major: A Case Report.

Alpha thalassemia major is a hemoglobinopathy caused by the inactivation or deletion of all 4 α-globin alleles. We describe a case of α-thalassemia major with atypical ultrasound and neuropathological findings. The mother had her first prenatal visit at 27 4/7 gestational weeks. Ultrasound revealed a hydropic fetus with multiple anomalies. However, the middle cerebral artery peak systolic velocity (MCA-PSV) suggested that the likelihood of fetal anemia was low. Given the poor prognosis of hydrops fetalis, the parents opted for termination of pregnancy. The neonate died shortly after birth. Autopsy revealed a markedly hydropic female infant with severe limb reduction defects and, in contrast to what was suggested by the prenatal MCA-PSV measurement, unequivocal signs of severe anemia. The brain showed diffuse white matter gliosis. Genetic testing subsequently identified HBA1 and HBA2 deletions, consistent with α-thalassemia major. This case highlights the potential pitfall of MCA-PSV, which is nowadays considered the gold standard for noninvasive detection of fetal anemia. In addition, this is 1 of 2 published case reports detailing neuropathological findings in a fetus or neonate with α-thalassemia major and the first to link α-thalassemia major with diffuse white matter gliosis.

A Challenging Prenatal QF-PCR Rapid Aneuploidy Test Result Caused by a Maternally Inherited Triplication within Chromosome Xq26.2.

The aim of this study was to investigate the origin of the biallelic trisomic amplification pattern of the X chromosome microsatellite marker DXS1187 in an otherwise normal male fetus, identified on routine rapid aneuploidy detection (RAD) testing by quantitative fluorescent-polymerase chain reaction (QF-PCR). Amniocentesis was performed on a 35-year-old female at 15 weeks, 2 days gestation for a positive first trimester screen. QF-PCR, metaphase FISH, and chromosomal microarray were carried out on both maternal and fetal DNA. Fetal QF-PCR showed a biallelic trisomic pattern for the X chromosome microsatellite marker DXS1187, with an otherwise normal male amplification pattern at all other sex chromosome markers. Chromosome analysis performed on cultured amniocytes showed a normal male karyotype. Chromosome microarray analysis identified a maternally inherited 304-kb copy number triplication within chromosome Xq26.2 encompassing the DXS1187 marker. The maternally inherited X chromosome harbors an apparently tandem 304-kb triplication that overlaps the DXS1187 marker. As the triplicated region is devoid of clinically relevant genes, it was considered as likely benign in the fetus. Postnatal follow-up reported a healthy male newborn. To our knowledge, this is a unique case demonstrating a "benign" copy number imbalance involving the DXS1187 marker detected by prenatal QF-PCR RAD.

Genotype-phenotype characterization in 13 individuals with chromosome Xp11.22 duplications.

We report 13 new individuals with duplications in Xp11.22-p11.23. The index family has one male and two female members in three generations with mild-severe intellectual disability (ID), speech delay, dysmorphic features, early puberty, constipation, and/or hand and foot abnormalities. Affected individuals were found to have two small duplications in Xp11.22 at nucleotide position (hg19) 50,112,063-50,456,458 bp (distal) and 53,160,114-53,713,154 bp (proximal). Collectively, these two regions include 14 RefSeq genes, prompting collection of a larger cohort of patients, in an attempt to delineate critical genes associated with the observed phenotype. In total, we have collected data on nine individuals with duplications overlapping the distal duplication region containing SHROOM4 and DGKK and eight individuals overlapping the proximal region including HUWE1. Duplications of HUWE1 have been previously associated with non-syndromic ID. Our data, with previously published reports, suggest that duplications involving SHROOM4 and DGKK may represent a new syndromic X-linked ID critical region associated with mild to severe ID, speech delay +/- dysarthria, attention deficit disorder, precocious puberty, constipation, and motor delay. We frequently observed foot abnormalities, 5th finger clinodactyly, tapering fingers, constipation, and exercise intolerance in patients with duplications of these two genes. Regarding duplications including the proximal region, our observations agree with previous studies, which have found associations with intellectual disability. In addition, expressive language delay, failure to thrive, motor delay, and 5th finger clinodactyly were also frequently observed in patients with the proximal duplication.

Prenatal Array Comparative Genomic Hybridization in Fetuses With Structural Cardiac Anomalies.

OBJECTIVES: To examine the diagnostic performance of array comparative genomic hybridization (CGH) for fetal cardiac anomalies in two medium-sized Canadian prenatal genetics clinics. METHODS: We prospectively recruited 22 pregnant women with fetal structural cardiac anomalies, normal rapid aneuploidy detection, and FISH for 22q11.2 testing for array CGH analysis. RESULTS: One case had an 8p deletion that was also visible on karyotype and included the GATA4 gene, which has been associated with congenital heart disease. Two cases had inherited pathogenic copy number variants (CNVs) of variable expressivity and penetrance: one was a duplication of 16p11.2 and the other a deletion of 15q11.2. One case had the incidental finding of being a carrier of a recessive disease unrelated to the cardiac anomaly. CONCLUSIONS: Of these prospectively recruited cases of fetal cardiac anomalies, 14% had a pathogenic result on array CGH. Pathogenic CNVs of variable penetrance and expressivity were a significant proportion of the positive results identified. These CNVs are generally associated with neurodevelopmental issues and may or may not have been associated with the fetus' underlying congenital heart disease. Array CGH increases the diagnostic yield in this group of patients; however, certain CNVs remain a challenge for counselling in the prenatal setting.

Refinement of the critical region of 1q41q42 microdeletion syndrome identifies FBXO28 as a candidate causative gene for intellectual disability and seizures.

A clinically recognizable syndrome associated with 1q41q42 microdeletion has recently been described in the literature (OMIM 612530). Patients with microdeletions in this region of chromosome 1 typically have developmental delay, characteristic dysmorphic features, and a predisposition to seizures. Malformations such as congenital diaphragmatic hernia and cleft lip have also been described. There has been considerable interest in mapping the smallest region of overlap for this syndrome in order to identify the critical pathogenic genes. The smallest region of overlap has recently been refined to a region encompassing four genes. Using array comparative genome hybridization (array CGH), we have identified a female with a 590-kB deletion within chromosome1q41q42. This patient's deletion further refines the previously defined region of overlap to a single gene, FBXO28. We propose that FBXO28 is a possible candidate causative gene contributing to the intellectual disability and seizure phenotype observed in 1q41q42 microdeletion syndrome.

Robust bioprocess design and evaluation of commercial media for the serial expansion of human induced pluripotent stem cell aggregate cultures in vertical-wheel bioreactors.

BACKGROUND: While pluripotent stem cell (PSC) therapies move toward clinical and commercial applications at a rapid rate, manufacturing reproducibility and robustness are notable bottlenecks in regulatory approval. Therapeutic applications of PSCs require large cell quantities to be generated under highly robust, well-defined, and economically viable conditions. Small-scale and short-term process optimization, however, is often performed in a linear fashion that does not account for time needed to verify the bioprocess protocols and analysis methods used. Design of a reproducible and robust bioprocess should be dynamic and include a continuous effort to understand how the process will respond over time and to different stresses before transitioning into large-scale production where stresses will be amplified. METHODS: This study utilizes a baseline protocol, developed for the short-term culture of PSC aggregates in Vertical-Wheel® bioreactors, to evaluate key process attributes through long-term (serial passage) suspension culture. This was done to access overall process robustness when performed with various commercially available media and cell lines. Process output variables including growth kinetics, aggregate morphology, harvest efficiency, genomic stability, and functional pluripotency were assessed through short and long-term culture. RESULTS: The robust nature of the expansion protocol was demonstrated over a six-day culture period where spherical aggregate formation and expansion were observed with high-fold expansions for all five commercial media tested. Profound differences in cell growth and quality were revealed only through long-term serial expansion and in-vessel dissociation operations. Some commercial media formulations tested demonstrated maintenance of cell growth rates, aggregate morphology, and high harvest recovery efficiencies through three bioreactor serial passages using multiple PSC lines. Exceptional bioprocess robustness was even demonstrated with sustained growth and quality maintenance over 10 serial bioreactor passages. However, some commercial media tested proved less equipped for serial passage cultures in bioreactors as cultures led to cell lysis during dissociation, reduction in growth rates, and a loss of aggregate morphology. CONCLUSIONS: This study demonstrates the importance of systematic selection and testing of bioprocess input variables, with multiple bioprocess output variables through serial passages to create a truly reproducible and robust protocol for clinical and commercial PSC production using scalable bioreactor systems.

Comprehensive analysis of mammalian miRNA* species and their role in myeloid cells.

Processing of pre-miRNA through Dicer1 generates an miRNA duplex that consists of an miRNA and miRNA* strand. Despite the general view that miRNA*s have no functional role, we further investigated miRNA* species in 10 deep-sequencing libraries from mouse and human tissue. Comparisons of miRNA/miRNA* ratios across the miRNA sequence libraries revealed that 50% of the investigated miRNA duplexes exhibited a highly dominant strand. Conversely, 10% of miRNA duplexes showed a comparable expression of both strands, whereas the remaining 40% exhibited variable ratios across the examined libraries, as exemplified by miR-223/miR-223* in murine and human cell lines. Functional analyses revealed a regulatory role for miR-223* in myeloid progenitor cells, which implies an active role for both arms of the miR-223 duplex. This was further underscored by the demonstration that miR-223 and miR-223* targeted the insulin-like growth factor 1 receptor/phosphatidylinositol 3-kinase axis and that high miR-223* levels were associated with increased overall survival in patients with acute myeloid leukemia. Thus, we found a supporting role for miR-223* in differentiating myeloid cells in normal and leukemic cell states. The fact that the miR-223 duplex acts through both arms extends the complexity of miRNA-directed gene regulation of this myeloid key miRNA.

Linkage of the potent leukemogenic activity of Meis1 to cell-cycle entry and transcriptional regulation of cyclin D3.

MEIS1 is a three-amino acid loop extension class homeodomain-containing homeobox (HOX) cofactor that plays key roles in normal hematopoiesis and leukemogenesis. Expression of Meis1 is rate-limiting in MLL-associated leukemias and potently interacts with Hox and NUP98-HOX genes in leukemic transformation to promote self-renewal and proliferation of hematopoietic progenitors. The oncogenicity of MEIS1 has been linked to its transcriptional activation properties. To further reveal the pathways triggered by Meis1, we assessed the function of a novel engineered fusion form of Meis1, M33-MEIS1, designed to confer transcriptional repression to Meis1 target genes that are otherwise up-regulated in normal and malignant hematopoiesis. Retroviral overexpression of M33-Meis1 resulted in the rapid and complete eradication of M33-Meis1-transduced normal and leukemic cells in vivo. Cell-cycle analysis showed that M33-Meis1 impeded the progression of cells from G(1)-to-S phase, which correlated with significant reduction of cyclin D3 levels and the inhibition of retinoblastoma (pRb) hyperphosphorylation. We identified cyclin D3 as a direct downstream target of MEIS1 and M33-MEIS1 and showed that the G(1)-phase accumulation and growth suppression induced by M33-Meis1 was partially relieved by overexpression of cyclin D3. This study provides strong evidence linking the growth-promoting activities of Meis1 to the cyclin D-pRb cell-cycle control pathway.

Apparent transmission distortion of a pericentric chromosome one inversion in a large multi-generation pedigree.

Pericentric chromosome inversions are often associated with infertility, recurrent pregnancy loss, and an increased risk for offspring with congenital anomalies. We report on a chromosome 1 inversion between 1p36.21 and 1q42.13, one of the largest described familial pericentric inversions of chromosome 1. The inversion was ascertained following the birth of a female with multiple congenital anomalies due to a recombinant chromosome 1. The inversion was subsequently detected or inferred in 16 healthy individuals over five generations. Interestingly, with a ratio of 16 carriers to 6 noncarriers, there appears to be transmission distortion of the inverted chromosome 1 within the family. Although there is no reported difficulty conceiving in the family, the risk of miscarriage is higher than predicted at 34% (13/38). The recurrence risk of a recombinant chromosome also appears to be lower than expected based on the mode of ascertainment. This case contributes to the spectrum of clinical features of chromosome 1 recombinants and raises the question of whether or not there is a selective advantage of the inverted chromosome at meiosis, conception, or post-zygotically that has contributed to transmission distortion of the inverted chromosome.

Hi-C detects genomic structural variants in peripheral blood of pediatric leukemia patients.

B-cell acute lymphoblastic leukemia (B-ALL) is often driven by chromosome translocations that result in recurrent and well-studied gene fusions. Currently, fluorescent in situ hybridization probes are used to detect candidate translocations in bone marrow samples from B-ALL patients. Recently Hi-C, a sequencing-based technique originally designed to reconstruct the three-dimensional architecture of the nuclear genome, was shown to effectively recognize structural variants. Here, we demonstrate that Hi-C can be used as a genome-wide assay to detect translocations and other structural variants of potential clinical interest. Structural variants were identified in both bone marrow and peripheral blood samples, including an ETV6-RUNX1 translocation present in one pediatric B-ALL patient. Our report provides proof of principle that Hi-C could be an effective strategy to globally detect driver structural variants in B-ALL peripheral blood specimens, reducing the need for invasive bone marrow biopsies and candidate-based clinical tests.

Modeling the functional heterogeneity of leukemia stem cells: role of STAT5 in leukemia stem cell self-renewal.

Although the cancer stem cell (CSC) concept implies that CSCs are rare, recent reports suggest that CSCs may be frequent in some cancers. We hypothesized that the proportion of leukemia stem cells would vary as a function of the number of dysregulated pathways. Constitutive expression of MN1 served as a 1-oncogene model, and coexpression of MN1 and a HOX gene served as a 2-oncogene model. Leukemia-initiating cell (LIC) number and in vitro expansion potential of LICs were functionally assessed by limiting dilution analyses. LIC expansion potential was 132-fold increased in the 2- compared with the 1-oncogene model, although phenotypically, both leukemias were similar. The 2-oncogene model was characterized by granulocyte-macrophage colony-stimulating factor (GM-CSF) hypersensitivity and activated STAT/ERK signaling. GM-CSF hypersensitivity of the 2-oncogene model (MN1/HOXA9) was lost in Stat5b(-/-) cells, and the LIC expansion potential was reduced by 86- and 28-fold in Stat5b(-/-) and Stat1(-/-) cells, respectively. Interestingly, in 201 acute myeloid leukemia (AML) patients, coexpression of MN1 and HOXA9 was restricted to patients with the poorest prognosis and was associated with highly active STAT signaling. Our data demonstrate the functional heterogeneity of LICs and show that STAT signaling is critical for leukemia stem cell self-renewal in MN1- and HOXA9-expressing leukemias.

Discordant phenotypes in a mother and daughter with mosaic supernumerary ring chromosome 19 explained by a de novo 7q36.2 deletion and 7p22.1 duplication.

We report on a patient with severe intellectual disability, microcephaly, short stature, and dysmorphic features who, based on standard karyotyping, has two cytogenetic abnormalities: an apparently balanced paracentric inversion of chromosome 7, inv(7)(q31.2q36), and a small supernumerary ring chromosome derived entirely of material from chromosome 19. While the inversion was detected in all cells, mosaicism was observed for the ring chromosome. Interestingly, apparently identical cytogenetic abnormalities were detected in the patient's mother, who presented with normal stature, few dysmorphic features, and normal cognition without microcephaly. While the level of mosaicism could not adequately explain the phenotypic discordance, comparative genome hybridization revealed a de novo terminal deletion of chromosome 7, del(7)(q36.2), and a terminal duplication of chromosome 7, dup(7)(p22.1) in the patient. Additional cytogenetic investigation revealed that the patient inherited a recombinant chromosome derived from a cryptic maternal pericentric inversion: inv(7)(p22q36). The patient's distinctive features are consistent with the wide phenotypic spectrum reported in 7p duplication and 7q terminal deletion syndromes. These chromosomal regions contain several candidate genes of clinical significance, including SHH, EN2, and FAM20C. Our findings strongly suggest that our patient's phenotype is largely attributable to partial 7pter trisomy and partial 7qter monosomy rather than mosaic supernumerary ring chromosome 19.

HLA-DR(negative), CD34(negative) hypergranular acute myeloid leukemia with trisomy 6 and del(5)(q22q33): case report and review of the literature.

We report a unique pediatric case of hypergranular acute myeloid leukemia with myelodysplasia-related changes. The patient presented with moderate leukocytosis with neutrophilia with left-shift maturation and dysplasia, anemia, and multiple sclerotic bone lesions. The bone marrow was hypercellular with a predominance of myeloblast cells and/or abnormal promyelocytes with hypergranular cytoplasm. Flow cytometric immunophenotyping showed that the leukemic cells were positive for CD13, CD33, and myeloperoxidase, and negative for HLA-DR and CD34. Morphology and immunophenotyping were highly suggestive of acute promyelocytic leukemia. The classic t(15;17) or other RARα rearrangements were not detected by cytogenetic or molecular assays, ruling out acute promyelocytic leukemia. Standard cytogenetic analysis showed that the karyotype of the predominant clone was 47,XY,+6 with evidence of clonal evolution to 47,XY,+6,del(5)(q22q33). A literature and database review showed that trisomy 6 is a rare occurrence in hematological malignancies and, to our knowledge, has never been reported in association with del(5)(q22q33) in a child presenting with hypergranular acute myeloid leukemia with myelodysplasia-related changes. We present a current review of the literature and summarize the clinical features of 57 cases of trisomy 6 as the primary chromosomal abnormality in hematological disease.

Very Low Vitamin D in a Patient With a Novel Pathogenic Variant in the GC Gene That Encodes Vitamin D-Binding Protein.

Circulating plasma vitamin D metabolites are highly bound to vitamin D-binding protein (DBP), also known as group-specific component or Gc-globulin. DBP, encoded by the GC gene, is a member of the albumin family of globular serum transport proteins. We previously described a homozygous GC gene deletion in a patient with apparent severe vitamin D deficiency, fragility fractures, and ankylosing spondylitis. Here, we report an unrelated patient free of fractures or rheumatologic disease, but with very low 25-hydroxyvitamin D and 1,25-hydroxyvitamin D, as well as undetectable DBP measured by liquid chromatography-tandem mass spectrometry. A whole gene deletion was excluded by microarray, and Sanger sequencing of GC revealed a homozygous pathogenic variant affecting a canonical splice site (c0.702-1G > A). These findings indicate that loss of function variants in GC that eliminate DBP, and severely reduced total circulating vitamin D levels, do not necessarily result in significant metabolic bone disease. Together with our previous report, these cases support the free-hormone hypothesis, and suggest free vitamin D metabolites may serve as preferable indicators of bone and mineral metabolism, particularly when clinical suspicion of DBP deficiency is high.

Overcoming bioprocess bottlenecks in the large-scale expansion of high-quality hiPSC aggregates in vertical-wheel stirred suspension bioreactors.

BACKGROUND: Human induced pluripotent stem cells (hiPSCs) hold enormous promise in accelerating breakthroughs in understanding human development, drug screening, disease modeling, and cell and gene therapies. Their potential, however, has been bottlenecked in a mostly laboratory setting due to bioprocess challenges in the scale-up of large quantities of high-quality cells for clinical and manufacturing purposes. While several studies have investigated the production of hiPSCs in bioreactors, the use of conventional horizontal-impeller, paddle, and rocking-wave mixing mechanisms have demonstrated unfavorable hydrodynamic environments for hiPSC growth and quality maintenance. This study focused on using computational fluid dynamics (CFD) modeling to aid in characterizing and optimizing the use of vertical-wheel bioreactors for hiPSC production. METHODS: The vertical-wheel bioreactor was modeled with CFD simulation software Fluent at agitation rates between 20 and 100 rpm. These models produced fluid flow patterns that mapped out a hydrodynamic environment to guide in the development of hiPSC inoculation and in-vessel aggregate dissociation protocols. The effect of single-cell inoculation on aggregate formation and growth was tested at select CFD-modeled agitation rates and feeding regimes in the vertical-wheel bioreactor. An in-vessel dissociation protocol was developed through the testing of various proteolytic enzymes and agitation exposure times. RESULTS: CFD modeling demonstrated the unique flow pattern and homogeneous distribution of hydrodynamic forces produced in the vertical-wheel bioreactor, making it the opportune environment for systematic bioprocess optimization of hiPSC expansion. We developed a scalable, single-cell inoculation protocol for the culture of hiPSCs as aggregates in vertical-wheel bioreactors, achieving over 30-fold expansion in 6 days without sacrificing cell quality. We have also provided the first published protocol for in-vessel hiPSC aggregate dissociation, permitting the entire bioreactor volume to be harvested into single cells for serial passaging into larger scale reactors. Importantly, the cells harvested and re-inoculated into scaled-up vertical-wheel bioreactors not only maintained consistent growth kinetics, they maintained a normal karyotype and pluripotent characterization and function. CONCLUSIONS: Taken together, these protocols provide a feasible solution for the culture of high-quality hiPSCs at a clinical and manufacturing scale by overcoming some of the major documented bioprocess bottlenecks.

CBL exon 8/9 mutants activate the FLT3 pathway and cluster in core binding factor/11q deletion acute myeloid leukemia/myelodysplastic syndrome subtypes.

PURPOSE: CBL is a negative regulator of activated receptor tyrosine kinases (RTK). In this study, we determined the frequency of CBL mutations in acute leukemias and evaluated the oncogenic potential of mutant CBL. EXPERIMENTAL DESIGN: The cDNA of 300 acute myeloid leukemia (AML)/myelodysplastic syndrome (MDS) and acute lymphoblastic leukemia (ALL) patients and 82 human leukemic cell lines was screened for aberrations in the linker and RING finger domain of CBL. The oncogenic potential of identified mutants was evaluated in hematopoietic cells. RESULTS: We identified 3 of 279 AML/MDS patients expressing CBL exon 8/9 deletion mutants. Three of four cases at diagnosis expressed deleted transcripts missing exon 8 or exon 8/9. In remission samples a weak or no expression of mutant CBL was detected. No aberrations were found in normal hematopoietic tissues. One of 116 sequenced AML/MDS cases carried a R420G missense mutation. All AML/MDS patients with identified CBL mutants belonged to the core binding factor and 11q deletion AML subtypes. Functionally, CBL negatively regulated FMS-like tyrosine kinase 3 (FLT3) activity and interacted with human FLT3 via the autophosphorylation sites Y589 and Y599 and colocalized in vivo. Expression of CBLDeltaexon8 and CBLDeltaexon8+9 in FLT3-WT-Ba/F3 cells induced growth factor-independent proliferation associated with autophosphorylation of FLT3 and activated the downstream targets signal transducer and activator of transcription 5 (STAT5) and protein kinase B (AKT). FLT3 ligand-dependent hyperproliferation of CBL mutant cells could be abrogated by treatment with the FLT3 PTK inhibitor PKC412 (midostaurin). CONCLUSION: CBL exon8/9 mutants occur in genetically defined AML/MDS subtypes and transform hematopoietic cells by constitutively activating the FLT3 pathway. This phenotype resembles the one of mutated RTKs and suggests that CBL mutant AML patients might benefit from treatment with FLT3 PTK inhibitors.

Optimized serial expansion of human induced pluripotent stem cells using low-density inoculation to generate clinically relevant quantities in vertical-wheel bioreactors.

Human induced pluripotent stem cells (hiPSCs) have generated a great deal of attention owing to their capacity for self-renewal and differentiation into the three germ layers of the body. Their discovery has facilitated a new era in biomedicine for understanding human development, drug screening, disease modeling, and cell therapy while reducing ethical issues and risks of immune rejection associated with traditional embryonic stem cells. Bioreactor-based processes have been the method of choice for the efficient expansion and differentiation of stem cells in controlled environments. Current protocols for the expansion of hiPSCs use horizontal impeller, paddle, or rocking wave mixing method bioreactors which require large static cell culture starting populations and achieve only moderate cell fold increases. This study focused on optimizing inoculation, agitation, oxygen, and nutrient availability for the culture of hiPSCs as aggregates in single-use, low-shear, vertical-wheel bioreactors. Under optimized conditions, we achieved an expansion of more than 30-fold in 6 days using a small starting population of cells and minimal media resources throughout. Importantly, we showed that that this optimized bioreactor expansion protocol could be replicated over four serial passages resulting in a cumulative cell expansion of 1.06E6-fold in 28 days. Cells from the final day of the serial passage were of high quality, maintaining a normal karyotype, pluripotent marker staining, and the ability to form teratomas in vivo. These findings demonstrate that a vertical-wheel bioreactor-based bioprocess can provide optimal conditions for efficient, rapid generation of high-quality hiPSCs to meet the demands for clinical manufacturing of therapeutic cell products.