Omega-3 fatty acids enriched chocolate spreads using soybean and coconut oils.

Chocolate spreads were developed by incorporating two different soybean oil margarines, fat phases prepared using 85 % soybean oil (M1) and 1:1 blend of soybean oil and coconut oil (M2) with commercial palm stearin. Eight formulations were tried by varying skim milk powder (SMP)/fluid skimmed milk (FSM), type of fats (M1, M2, a commercial margarine and a table spread), sugar and cocoa powder and their quality characteristics were compared with a commercial hazelnut cocoa spread. The moisture and fat content were 5-6.1 % and 31.4-32.8 % for formulations with SMP and 21.5-24.7 % and 15.6-21.4 % respectively for those with FSM. Rheological studies of FSM spreads showed higher G″ value (loss modulus) than G' (storage modulus) indicating better spreadability. Descriptive sensory analysis revealed that the products had acceptability score of 8.3 to 10.5 (maximum score: 15). Fat extracted from spreads prepared using M1 and M2 was found to contain 43.9 and 22.3 % linoleic acid and 2.1 and 4.4 % linolenic acid respectively, were free from trans fat while the commercial hazelnut spread had 9.8 % linoleic acid but did not contain linolenic acid. Hence, the developed chocolate spreads have the potential to overcome ω-3 deficiency, ω-6/ω-3 imbalance and to enhance the health standard of people.

Studies on the nutraceuticals composition of wheat derived oils wheat bran oil and wheat germ oil.

Fat-soluble nutraceuticals of cereals are known for number of disease preventive activities. Hence wheat bran oil (WBO) and wheat germ oil (WGO) were extracted from wheat bran and germ which yielded 3.35 % and 7.35 % of oil, containing polyunsaturated fatty acids (PUFA) (64 %, 61.2 %) respectively. Both oils contained tocopherols and carotenoids, which were higher in wheat germ oil (273 mg/100 g, 12.23 mg/100 g) than wheat bran oil (190 mg/100 g, 2.21 mg/100 g). Steryl ferulates were also present in both the oils, but their content was eight-fold higher in WBO than in WGO. Three major steryl ferulates identified by HPLC were campesteryl ferulate and sitostenyl ferulate, campestanyl ferulate and ß-sitosteryl ferulate as in γ-oryzanol and another ferulate, viz., sitostanyl ferulate. A strong IC50 value of 7.5 mg/mL and 21.6 mg/mL DPPH free radicals scavenging for wheat germ oil for wheat bran oil was observed. NMR ((13)C and (1)H) profile explored the evidence of distribution of antioxidant molecules in the unsaponifiable matter of wheat derived oil. Since oils rich in PUFA and minor components are required for the normal physiological activities, blending such oils with other edible oils of the diet in wheat growing countries like India may be useful to provide health benefits.

Physico-chemical characteristics and stability aspects of coconut water and kernel at different stages of maturity.

Coconut water and kernel are the edible portions of the coconut. A study was carried out to evaluate the physico-chemical characteristics, phytonutrients and stability of coconut water (CW), kernel (CK) at different stages of maturity and commercial coconut products (CCP). The moisture content of CW, CK and CCP were in the range of 95-97 g 100 g(-1), 50-85 g 100 g(-1) and 0.4-3 g 100 g(-1) respectively. Fat content in CW was low (4-115 mg 100 g(-1)) whereas in kernel it was high (37-56 g 100 g(-1)). The CW was acidic in nature (pH 4.5-5.2). Ash content of CK decreased with maturity (1.0-1.5 %) whereas that of CW remained steady (0.3-0.4 g 100 g(-1)) with maturity. The total sugar content (3.9-4.6 g 100 g(-1)) and acidity (0.3-0.4 g 100 g(-1)) of CW did not change with maturity. The phenolics content increased in water (1.4-4.3 mg 100 g(-1)) and kernel with maturity (18.5-24.8 mg 100 g(-1)). The fatty acid composition of the oil extracted from the CK had increased saturated fatty acids (C12:0) (38-48 g 100 g(-1)) and decreased monounsaturated fatty acid (C18:1) (13-5 g 100 g(-1)) with maturity. The percentage of medium chain fatty acids increased with different stages of maturity (47-78 g 100 g(-1)). The CW and CK contained higher amount of phenolics (1.4-4.3 mg 100 g(-1) and 18.5-24.8 mg 100 g(-1) respectively) and total tocopherols of CK (0.14-0.59 mg 100 g(-1)) when compared to CCP. This study indicated that CW and CK could serve as valuable raw materials for the preparation of functional food supplement.

Retention of natural antioxidants of blends of groundnut and sunflower oils with minor oils during storage and frying.

Unrefined groundnut oil (GNO) and refined sunflower oil (SFO) were blended with four minor oils including laboratory refined red palmolein (RRPO), physically refined rice bran oil (RBO), unrefined sesame oil (SESO), and unrefined coconut oil (CNO) containing natural antioxidants viz., ß-carotene, tocopherols, oryzanol and lignans. The five blends prepared were GNO + RRPO (80:20), GNO + RBO (80:20), GNO + SESO (80:20), SFO + RRPO (50:50) and SFO + CNO (60:40). Prepared blends contained saturated fatty acids (SFA) (16.7-53.3 %); monounsaturated fatty acids (MUFA) (16.0-45.5 %) and polyunsaturated fatty acids (PUFA) (29.2-37.8 %). GNO blends viz., GNO + RRPO, GNO + RBO and GNO + SESO contained ß-carotene (10.7 mg/100 g), oryzanol (0.12 g/100 g) and lignans (0.35 g/100 g) respectively as natural antioxidants. SFO was enriched with ß-carotene (28.7 mg/100 g) and medium chain fatty acids (34.2 %) by blending with RRPO and CNO respectively. The oil blends (200 ml) were packed and stored at 38 °C/90 % relative humidity (RH) and 27 °C/65 % RH and samples were withdrawn at fixed intervals for analysis. Freshly prepared blends were also investigated for their frying performance. During storage, GNO + RBO blend showed highest oxidative stability probably due to the presence of oryzanol in the order GNO + RBO > GNO + SESO > GNO + RRPO. During frying, the peroxide value of GNO blends with RBO (rich in oryzanol) and SESO (rich in lignans) was less while the free fatty acid value was less in SFO blends with RRPO and CNO. Hence, blending of natural antioxidants rich minor oils (RRPO, RBO and SESO) with the major vegetable oils (GNO and SFO) may preserve them by lowering their rate of oxidation during storage and frying.

Fat-soluble nutraceuticals and their composition in heat-processed wheat germ and wheat bran.

Nutraceuticals availability in heat-processed foods is considered to be the index for healthy food. This study has made an attempt to optimize the temperature to retain nutraceuticals in wheat bran (WB) and wheat germ (WG). Heated WG (130 °C & 140 °C) and WB (140 °C & 150 °C) were analyzed for sensory profiles. Extracted oils were subjected to physicochemical parameter as well as its nutraceuticals. Increased oil yield, color values and reduced free fatty acids were found with varied temperatures. Fat-soluble compounds total tocols, steryl ferulates and carotenoids found in WG (0.316, 0.058 and 0.011%) and WB (0.228, 0.595 and 0.015%) and maximum reductions started in WG (0.183%, 0.034% and 0.004%) at 130 °C. The free radical-scavenging activities of control samples showed high EC50 values than processed samples; however, no differences were observed between two temperatures. Study may clearly spell out that the reduced nutraceuticals observed after subjecting food raw materials to optimum temperature eventually lead to its quality.

Hypolipidemic effect of oryzanol concentrate and low temperature extracted crude rice bran oil in experimental male wistar rats.

Blends of refined groundnut oil (GNO) and oryzanol concentrate having 3, 5, and 10% oryzanol in the blend, and a rice bran oil (RBO) which had retained all the nutrients such as oryzanol, tocopherols and tocotrienols and the unsaponifiable matter components of crude oil (GWF RBO) were prepared. Weanling rats were fed with diet containing the oil blends/rice bran oil at 10% level for 60 days and then dissected. The lipid profiles in serum, liver were investigated and the cholesterol levels were marginally reduced (7-16% in serum, 10-14.5% in liver) in rats fed oryzanol containing diet. RBO, GWF RBO containing diets showed a reduction of serum cholesterol by 14%, 15% respectively when compared to those fed with GNO. Serum and liver lipid analysis also showed significant change in TG concentration in rats fed blended oils containing oryzanol compared to the rats given GNO. Histology of liver and kidneys did not show changes. These studies indicated that oryzanol has an effect in lowering serum and liver cholesterol and shows antiatherogenic properties when incorporated into groundnut oil.