Influence of cocoa products on rheological, fatty acid profile and quality characteristics of biscuits.

Cocoa products namely cocoa powder (CP), cocoa butter (CB) and cocoa mass (CM) were selected for their utilization in soft dough biscuits. CP was blended with the refined wheat flour (WF-0, 5, 10 and 15% levels) and rheological and quality characteristics of biscuits were studied. The spread ratio decreased (10.1-8.8), density (0.49-0.52 g/cm3) and breaking strength values (1127-1369 g force) increased gradually with increase in CP. Combination of GMS and SSL at 0.25% each improved the quality of biscuits at 10% incorporation of CP. Further the biscuit fat (BF) was replaced with CB (0, 25, 50 and 75%). Later the biscuits with CM were prepared by replacing the flour (15%) and BF (0, 25, 50 and 75%). Acceptability of the CM based biscuits was better when compared to CB based biscuits. The total polyphenol content in control biscuits was 55.55 mg/100 g and was in the range between 81.98 and 102.05 mg/100 g for cocoa based biscuits. The protein content in cocoa based biscuits was marginally higher than the control biscuit. Though there was a wide variation in the fat content and different fatty acids in raw materials, interestingly, the values varied narrowly in biscuits.

Cell surface ATP synthase-released H+ and ATP play key roles in cocoa butter intake-mediated regulation of gut immunity through releases of cytokines in rat.

Proper food intake is important for maintaining good health in humans. Chocolate is known to exert anti-inflammatory effects; however, the mechanisms remain unclear. In this study, we aimed to investigate the effects of cocoa butter intake on gut immunity in rats and rabbits. Cocoa butter intake increased the lymph flow, cell density, and IL-1ß, IL-6 and IL-10 levels in mesenteric lymph. Clodronate, a macrophage depletion compound, significantly enhanced the release of all cytokines. The immunoreactivities of macrophage markers CD68 and F4/80 in the jejunal villi were significantly decreased with clodronate. Piceatannol, a selective cell surface ATP synthase inhibitor significantly reduced the cocoa butter intake-mediated releases of IL-1ß, IL-6 and IL-10. The immunoreactivities of cell surface ATP synthase were observed in rat jejunal villi. Shear stress stimulation on the myofibroblast cells isolated from rat jejunum released ATP and carbon dioxide depended with H+ release. In rabbit in vivo experiments, cocoa butter intake increased the concentrations of ATP and H+ in the portal vein. The in vitro experiments with isolated cells of rat jejunal lamina propria the pH of 3.0 and 5.0 in the medium released significantly IL-1ß and IL-6. ATP selectively released IL-10. These findings suggest that cocoa butter intake regulates the gut immunity through the release and transport of IL-1ß, IL-6, and IL-10 into mesenteric lymph vessels in a negative feedback system. In addition, the H+ and ATP released from cell surface ATP synthase in jejunal villi play key roles in the cocoa butter intake-mediated regulation of gut immunity.

Mastering targeted genome engineering of GC-rich oleaginous yeast for tailored plant oil alternatives for the food and chemical sector.

BACKGROUND: Sustainable production of triglycerides for various applications is a major focus of microbial factories. Oleaginous yeast species have been targeted for commercial production of microbial oils. Among all the oleaginous yeasts examined in a previous comparative study, Cutaneotrichosporon oleaginosus showed the highest lipid productivity. Moreover, a new lipid production process for C. oleaginosus with minimal waste generation and energy consumption resulted in the highest lipid productivity in the history of oleaginous yeasts. However, productivity and product diversity are restricted because of the genetic intractability of this yeast. To date, successful targeted genetic engineering of C. oleaginosus has not yet been reported. RESULTS: The targeted gene editing was successfully carried out in C. oleaginosus using CRISPR/Cas system. A tailored enzyme system isolated to degrade the C. oleaginosus cell wall enabled the isolation of viable spheroplasts that are amenable to in-cell delivery of nucleic acids and proteins. The employment of both Cas9 protein and Cas mRNA was effective in obtaining strains with URA5 knockout that did not exhibit growth in the absence of uracil. Subsequently, we successfully created several strains with enhanced lipid yield (54% increase compared to that in wild type) or modified fatty acid profiles comparable with those of cocoa butter or sunflower oil compositions. CONCLUSION: This study establishes the first targeted engineering technique for C. oleaginosus using the CRISPR/Cas system. The current study creates the foundation for flexible and targeted strain optimizations towards building a robust platform for sustainable microbial lipid production. Moreover, the genetic transformation of eukaryotic microbial cells using Cas9 mRNA was successfully achieved.

Triacylglycerol Composition and Chemical-Physical Properties of Cocoa Butter and Its Derivatives: NMR, DSC, X-ray, Rheological Investigation.

In recent years, the food industry has become increasingly involved in researching vegetable fats and oils with appropriate mechanical properties (ease of transport, processing, and storage) and a specific lipidic composition to ensure healthy products for consumers. The chemical-physical behavior of these matrices depends on their composition in terms of single fatty acids (FA). However, as we demonstrate in this work, these properties, as well as the absorption, digestion and uptake in humans of specific FAs, are also largely determined by their regiosomerism within the TriAcylGlycerols (TAG) moieties (sn-1,2,3 positions). The goal of this work is to study for the first time vegetable fats obtained directly from a sample of natural cocoa butter (CB) through a process that manipulates the distribution of FAs but not their nature. Even if the initial percentage of each FA in the mixture remains the same, CB derivatives seem to show improved chemical-physical features. In order to understand which factors account for their physical and chemical characteristics, and to check whether or not the obtained new matrices could be considered as valid alternatives to other vegetable fats (e.g., palm oil (PO)), we carried out an experimental investigation at both the macroscopic and molecular level including: (i) Differential Scanning Calorimetry (DSC) analyses to examine thermal features; (ii) rheological testing to explore mechanical properties; (iii) powder X-ray diffraction (PXRD) to evaluate the solid-state phases of the obtained fats; and (iv) 1H and 13C Nuclear Magnetic Resonance (NMR, 1D and 2D) spectroscopy to rapidly analyze fatty acid composition including regioisomeric distribution on the glycerol backbone. These last results open up the possibility of using NMR spectroscopy as an alternative to the chromatographic techniques routinely employed for the investigation of similar matrices.

The impact of roasting on cocoa quality parameters.

Roasting is an essential process in cocoa industry involving high temperatures that causes several physicochemical and microstructural changes in cocoa beans that ensure their quality and further processability. The versatility in roasting temperatures (100 - 150 °C) has attracted the attention of researchers toward the exploration of the effects of different roasting conditions on the color, proximal composition, cocoa butter quality, concentration of thermolabile compounds, formation of odor-active volatile organic compounds, generation of melanoidins, production of thermal processes contaminants in cocoa nibs, among others. Some researchers have drowned in exploring new roasting parameters (e.g., the concentration of water steam in the roasting chamber), whilst others have adapted novel heat-transfer techniques to cocoa nibs (e.g., fluidized bed roasting and microwaves). A detailed investigation of the physicochemical phenomena occurring under different cocoa roasting scenarios is lacking. Therefore, this review provides a comprehensive analysis of the state of art of cocoa roasting, identifies weak and mistaken points, presents research gaps, and gives recommendations to be considered for future cocoa studies.

Supercritical fluid chromatography coupled to high-resolution tandem mass spectrometry: an innovative one-run method for the comprehensive assessment of chocolate quality and authenticity.

To assess chocolate quality and authenticity comprehensively, a combination of various analytical procedures is involved, thereby making the process time-consuming and costly. Thus, we investigated the potential of ultra-high performance supercritical fluid chromatography coupled to quadrupole-time of flight mass spectrometry (UHPSFC-QTOF-MS) as an alternative to "classic" methods. By combining hexane and aqueous extracts from sequential extraction, a single 8-min analytical run enabled us (i) to determine cocoa butter equivalents (CBEs) and milk fat content based on the detection of selected triacylglycerols, (ii) to calculate dry non-fat cocoa solids based on determined theobromine and caffeine content, and (iii) to profile contained sugars. To obtain the most comprehensive information about sample composition, the MS method comprised a full MS scan for non-target screening and several time-scheduled targeted MS/MS functions ("parallel reaction monitoring") optimized according to the possible concentration ranges of the analytes. For 40 different chocolate samples, our results and those obtained by using standard methods (LC-UV for non-fat cocoa solids, and GC-FID for CBEs) were in good agreement. Compared to the conventional approach for chocolate quality and authenticity control, the presented SFC-MS method is a fast, cost-effective, and efficient alternative, and only samples suspicious for the presence of CBE should be referred to the standard GC-FID method for exact CBE quantification. In the study, also some challenges offered by SFC-MS have been addressed.

Rational Design of Lipase ROL to Increase Its Thermostability for Production of Structured Tags.

1,3-regiospecific lipases are important enzymes that are heavily utilized in the food industries to produce structured triacylglycerols (TAGs). The Rhizopus oryzae lipase (ROL) has recently gained interest because this enzyme possesses high selectivity and catalytic efficiency. However, its low thermostability limits its use towards reactions that work at lower temperature. Most importantly, the enzyme cannot be used for the production of 1,3-dioleoyl-2-palmitoylglycerol (OPO) and 1,3-stearoyl-2-oleoyl-glycerol (SOS) due to the high melting points of the substrates used for the reaction. Despite various engineering efforts used to improve the thermostability of ROL, the enzyme is unable to function at temperatures above 60 °C. Here, we describe the rational design of ROL to identify variants that can retain their activity at temperatures higher than 60 °C. After two rounds of mutagenesis and screening, we were able to identify a mutant ROL_10x that can retain most of its activity at 70 °C. We further demonstrated that this mutant is useful for the synthesis of SOS while minimal product formation was observed with ROL_WT. Our engineered enzyme provides a promising solution for the industrial synthesis of structured lipids at high temperature.

Fast Melt Cocoa Butter Tablet: Effect of Waxes, Starch, and PEG 6000 on Physical Properties of the Preparation.

A fast melt tablet (FMT) is well regarded as an alternative delivery system that might help resolve a patient's non-compliance issue. The main objective of this study was to develop a cocoa butter-based FMT. Additives, namely 5-15% of PEG 6000, beeswax, paraffin wax, and corn starch, were incorporated into the cocoa butter-based FMT to study the effects of these additives with the physical characteristic of a cocoa butter FMT. An optimum-based formulation was chosen according to the desired hardness and disintegration time and the taste masking property achieved with the model drug-dapoxetine. The analysis demonstrated that incorporating beeswax (15%) and paraffin wax (15%) could prolong the disintegration time by at least two-fold. On the contrary, the presence of corn starch was found to cause an increase in the hardness and reduction of the disintegration time. The disintegration mechanism might be presumed due to the synergistic effect of starch swelling and cocoa butter melting. The hardness value and in vitro disintegration time of the optimum formulation were recorded at 2.93 ± 0.22 kg and 151.67 ± 6.98 s. In terms of dissolution, 80% of dapoxetine was released within 30 min and the dissolution profile was comparable to the innovator product. The formulation was palatable and stable for at least 1 year. The exposure of the FMT formulation at 30 °C for 12 months was reported to be stable. Along with the sound palatability profile and high drug load capacity, the current formulation possesses the desired characteristics to be scaled up and marketed.

Quantification of Porous Properties of Shear Crystallized Lipids.

The aim of this study was to investigate the impact that shear and composition have on the structural properties associated with the porous phases of lipids. To accomplish this aim, we developed eight main crystallized samples using cocoa butter (CB) or trilaurin (TL) in the presence or absence of monostearate (M) (5% w/w). The samples were sheared at 500 s-1 using random (RS) or laminar (LS) shear at a cooling rate of 2 °C/min. Using the maximal ball (MB) algorithm, several empirical void measurements such as connectivity (z), pore and throat volume weighted radii (R43), and void fraction (v) were quantified using 3D X-ray microcomputed tomography images. Most void features were identified as micropores (R ≥ 10 µm) possibly originating from the crystallization process and post-process crystal growth. Likewise, depending on the applied treatments, mechanisms impacting void formation were found to produce noticeable variation in v (0.019 to 0.139) and to determine whether void morphology was spherical, irregular, and/or highly connected.

Synthesis of cocoa butter alternatives from palm kernel stearin, coconut oil and fully hydrogenated palm stearin blends by chemical interesterification.

BACKGROUND: Chemical interesterification (CIE) is one of the important technological processes for the production of zero-trans fats. The aim of this study was to produce trans-free cocoa butter alternatives (CBAs) from palm kernel stearin (PKS), coconut oil (CNO) and fully-hydrogenated palm stearin (FHPS) blends via CIE using sodium methoxide as a catalyst. The physicochemical properties, crystallization and melting behavior, solid fat content (SFC), crystal morphology and polymorphism of the structured lipids (SLs) obtained and the corresponding physical blends (PBs) were characterized and compared with commercial CBAs. RESULTS: After CIE, randomization of fatty acid distribution within and among triacylglycerol (TAG) molecules of PKS, CNO and FHPS resulted in a modification in TAG compositions of the PKS/CNO/FHPS blends and improved the properties and crystallization behavior of the blends. SFC and slip melting points of all SLs decreased from those of their respective PBs. In particular, SLs obtained from CIE of blends with 60-70% wt. PKS (blend ratios 60:10:30 and 70:10:20) exhibited the melting characteristic, SFC curves, crystal morphology and polymorphic form most similar to the commercial CBAs. In addition, these blends melted almost completely at body temperature, an improvement from that of the commercial CBAs. CONCLUSION: SLs obtained from CIE of blends with 60-70% wt. PKS has high potential to be used commercially as trans-free CBAs for the confectionery industry. © 2021 Society of Chemical Industry.

Improving the crystallization and melting characteristics of cocoa butter substitute by blending with krabok seed fat.

This work investigated the crystallization and melting behavior of a commercial cocoa butter substitute (CBS) blended with 10-80% (by weight) of a hard lauric fat called krabok seed fat (KSF). The aim was to find CBS-KSF blends with improved crystallization and melting characteristics from that of the CBS. It was found that the addition of 10-80% KSF to CBS improved the melting properties of the CBS. However, 10-20% KSF resulted in too high solid fat content (SFC) values at the body temperature (37 °C) which would lead to waxy mouth feel. Adding 30-40% KSF resulted in better melting profiles than 10-20% KSF with SFC values < 3% at 37 °C and SFC curves most similar to cocoa butter. However, 40% KSF led to a significant decrease in the crystallization rate from that of CBS and a significant increase in the average crystal size. With 60-80% KSF, although the blends melted completely at the body temperature, their crystallization rates were significantly reduced. All CBS-KSF blends crystallized into ß' structure. Therefore, the addition of 30% KSF to the CBS is recommended for industrial use to obtain compound chocolate with improved quality. Supplementary Information: The online version contains supplementary material available at 10.1007/s13197-022-05513-1.

Continuous production of monoacylglycerol via glycerolysis of babassu oil by immobilized Burkholderia cepacia lipase in a packed bed reactor.

This study investigated the glycerolysis of babassu oil by Burkholderia cepacia lipase immobilized on SiO2-PVA particles in a continuous packed bed reactor. Experiments were conducted in a solvent-free system at 273.15 K either in an inert atmosphere or in the presence of cocoa butter to prevent lipid oxidation. The reactor (15 × 55 mm) was run at a fixed space time of 9.8 h using different molar ratios of babassu oil to glycerol (1:3, 1:6, 1:9, 1:12, and 1:15) to assess the effects of reactant molar ratio on monoacylglycerol productivity and selectivity. Nitrogen atmosphere and cocoa butter were equally effective in inhibiting lipid oxidation, indicating that addition of cocoa butter to glycerolysis reactions may be an interesting cost-reduction strategy. An oil/glycerol molar ratio of 1:9 resulted in the highest productivity (52.3 ± 2.9 mg g-1 h-1) and selectivity (31.5 ± 1.8%). Residence time distribution data were fitted to an axial dispersion model for closed-vessel boundary conditions, giving a mass transfer coefficient (kc) of 3.4229 × 10-6 m s-1. A kinetic model based on elementary steps of the studied reaction was written in Scilab and compared with experimental data, providing standard deviations in the range of 5.5-7.5%.

Preparation of Low-Diacylglycerol Cocoa Butter Equivalents by Hexane Fractionation of Palm Stearin and Shea Butter.

Herein, we prepared 1,3-dipalmitoyl-2-oleoyl glycerol (POP)-rich fats with reduced levels of diacylglycerols (DAGs), adversely affecting the tempering of chocolate, via two-step hexane fractionation of palm stearin. DAG content in the as-prepared fats was lower than that in POP-rich fats obtained by previously reported conventional two-step acetone fractionation. Cocoa butter equivalents (CBEs) were fabricated by blending the as-prepared fats with 1,3-distearoyl-2-oleoyl glycerol (SOS)-rich fats obtained by hexane fractionation of degummed shea butter. POP-rich fats achieved under the best conditions for the fractionation of palm stearin had a significantly lower DAG content (1.6 w/w%) than that in the counterpart (4.6 w/w%) prepared by the previously reported method. The CBEs fabricated by blending the POP- and SOS-rich fats in a weight ratio of 40:60 contained 63.7 w/w% total symmetric monounsaturated triacylglycerols, including 22.0 w/w% POP, 8.6 w/w% palmitoyl-2-oleoyl-3-stearoyl-rac-glycerol, 33.1 w/w% SOS, and 1.3 w/w% DAGs, which was not substantially different from the DAG content in cocoa butter (1.1 w/w%). Based on the solid-fat content results, it was concluded that, when these CBEs were used for chocolate manufacture, they blended with cocoa butter at levels up to 40 w/w%, without distinctively altering the hardness and melting behavior of cocoa butter.

Development and Evaluation of Cocoa Butter Taste Masked Ibuprofen Using Supercritical Carbon Dioxide.

Masking the unpleasant taste of the pharmaceutically active ingredients plays a critical role in patient acceptance, particularly for children. This work's primary objective was the preparation of taste-masked ibuprofen microparticles using cocoa butter with the assistance of supercritical fluid technology. Microparticles were prepared by dissolving ibuprofen in melted cocoa butter at 40 °C. The solution was then introduced into a supercritical fluid unit and processed at 10 MPa CO2 pressure for 30 min. The product was collected after depressurizing the system. The effect of the drug to cocoa butter ratio and the supercritical fluid units' configuration on product quality was evaluated and compared with the sample prepared by a conventional method. Physicochemical characterization of the prepared product, including particle size, crystallinity, entrapment efficiency, in vitro drug release, and product taste using a human volunteer panel was conducted. The produced microparticles were in the range of 1.42 to 15.28 µm. The entrapment efficiency of the formulated microparticles ranged from 66 to 81%. The drug:polymer ratio, the configuration of the supercritical fluid unit, and the method of preparation were found to have a critical role in the formulation of ibuprofen microparticles. Taste evaluation using human volunteers showed that microparticles containing 20% drug and processed with supercritical fluid technology were capable of masking the bitter taste of ibuprofen. In conclusion, the dispersion of ibuprofen in cocoa butter using supercritical fluid technology is a a promising innovative method to mask the bitter taste of ibuprofen.

Mango kernel fat fractions as potential healthy food ingredients: A review.

Mango kernel fat (MKF) has been reported to have high functional and nutritional potential. However, its application in food industry has not been fully explored or developed. In this review, the chemical compositions, physical properties and potential health benefits of MKF are described. MKF is a unique fat consisting of 28.9-65.0% of 1,3-distearoyl-2-oleoyl-glycerol with excellent oxidative stability index (58.8-85.2 h at 110 °C), making the fat and its fractions suitable for use as high-value added food ingredients such as cocoa butter alternatives, trans-free shortenings, and a source of natural antioxidants (e.g., sterol, tocopherol and squalene). Unfortunately, the long period of dehydration of mango kernels at hot temperature results in the hydrolysis of triacylglycerols. The high levels of hydrolysates (mainly free fatty acids and diacylglycerols) limit the application of MKF in manufacturing these food ingredients. It is suggested that the physico-chemical and functional properties of MKF could be further improved through moderated refining (e.g., degumming and physical deacidification), fractionation, and interesterification.

A comparative study of the effects of palm olein, cocoa butter and extra virgin olive oil on lipid profile, including low-density lipoprotein subfractions in young healthy Chinese people.

The aim of this study is to investigate the effects of palm olein (POL), cocoa butter (CB) and extra virgin olive oil (EVOO) on the lipid profile and low-density lipoprotein subfractions in a young, healthy Chinese population. After screening, 72 subjects were randomly assigned to three groups, and an 18-week randomized crossover trial was conducted. The first phase was a 2-week run-in period, followed by three phases of the 4-week experimental periods with a 2-week washout period between experimental periods. Three groups of subjects alternately consumed a Chinese diet enriched with the different test oils. The various indices of subjects were collected before and after each experimental period. Sixty-seven subjects completed the study, and there were no significant differences in conventional indices amongst the three groups at the beginning of the three experimental periods (p > .05). Each test oil accounted for approximately 40% of total fat intake and approximately 11.3% of the total energy supply. After controlling for dietary interventions, only the serum triglyceride level of the POL-Diet was significantly lower than that of the EVOO-Diet (p = .034), and most indices did not significantly differ amongst the three test oil diets (p > .05). POL, CB and EVOO have almost identical effects on serum lipids.

Changes of Phytosterols, Rheology, Antioxidant Activity and Emulsion Stability of Salad Dressing with Cocoa Butter During Storage.

Addition of phytosterols and antioxidants to food may provide additional health benefits to consumers. Their stability in a food matrix may decrease during storage. Therefore, the objectives of this study are to formulate a salad dressing with cocoa butter and determine its phytosterol stability, antioxidant activity and physicochemical properties during storage. The cocoa butter was extracted using a supercritical CO2 extraction (green technology) and added to the formulated salad dressing (containing different ratios of cocoa butter and soybean oil). The salad dressing with 30% cocoa butter (the most stable emulsion) was selected for storage study at 4 and 30 °C. However, values of physicochemical parameters and mass fractions of phytosterols, total phenolic compounds (determined using Folin-Ciocalteu reagent) and 2,2-diphenyl-1-picrylhydrazyl (DPPH) in the salad dressing with 30% cocoa butter decreased during storage (from day 0 to 28) and increased with the temperature increase, probably due to the oxidation of oil. Thus, the most desirable storage temperature for salad dressing was 4 °C. An excellent stability of the salad dressing with 30% cocoa butter at different storage temperatures for 28 days offers a potential application in food industries for production of salad dressing with cocoa butter enriched with phytosterols.

Occurrence of oleaginous yeast from mangrove forest in Thailand.

A total of 191 yeasts were isolated from 197 samples collected from eight estuarine mangrove forests along four different coastlines of Thailand (Andaman Sea and the East, North and West coasts of the Gulf of Thailand). Of these, 178 isolates were identified as 32 species in 16 genera of Ascomycota, 12 species in nine genera of Basidiomycota, and 13 isolates as potential new species, respectively. Mangroves located along the Andaman Sea coastline had a higher yeast diversity at the species and genera levels than those along the Gulf of Thailand. Kluyveromyces siamensis was the most frequently isolated species, whilst Candida tropicalis was the only species isolated at all eight sites. Screening isolated yeast strains belonging to genera previously reported as oleaginous yeast plus the 13 potential new species, revealed two oleaginous strains, Rhodotorula sphaerocarpa 11-14.4 and Saitozyma podzolica 11-11.3.1. Both of these strains were isolated from the same mangrove forest on the Andaman Sea coastline. They could accumulate lipid when suspended in glucose solution without any supplementation, while the fatty acid composition and oil profile of Rh. sphaerocarpa 11-14.4 and Sait. podzolica 11-11.3.1 were similar to vegetable oil and cocoa butter, respectively.

Synthesis of cocoa butter substitutes from Cinnamomum camphora seed oil and fully hydrogenated palm oil by enzymatic interesterification.

Cinnamomum camphora trees have a vast range of distribution in southern China and the seed oil has unique fatty acid (FA) properties and various bio-activities. In this work, Cinnamomum camphora seed oil (CCSO) was utilized to synthesize value-added cocoa butter substitute (CBS) by enzymatic interesterification. The synthesis was conducted in a solvent-free system by blending CCSO with fully hydrogenated palm oil under the catalysis of Lipozyme RM IM. The reacted products were assessed with physicochemical properties, i.e. FA composition, slip melting point (SMP), triacylglycerol (TAG), crystal polymorphism, microstructure, melting and crystallization properties and solid fat content (SFC). It showed that MCFAs (capric acid plus lauric acid) was the main fatty acid in products, accounting for over 45%. Comparing to physical blends, some novel TAG species such as LaLaLa and LaMLa/LaLaM were observed after enzymatic interesterification whereas SSS TAGs were reduced. IP presented a ball-like, well-distributed and nearly round crystal microstructure and a smaller crystal size. Moreover, it should be mentioned that SFC of IP ranging from 31.85 to 38.47% at 25 °C with most ß' crystal forms, was beneficial to improve the spreadability in term of confectionery products and baked goods. The SMP of the interesterified products was 35.75-36.15 °C which closed to the commercial CBS. Hence, the products synthesized can be used to as CBS, and the results in this study also showed CCSO have value-added applications.

Modulation of saturation and chain length of fatty acids in Saccharomyces cerevisiae for production of cocoa butter-like lipids.

Chain length and degree of saturation plays an important role for the characteristics of various products derived from fatty acids, such as fuels, cosmetics, and food additives. The seeds of Theobroma cacao are the source of cocoa butter, a natural lipid of high interest for the food and cosmetics industry. Cocoa butter is rich in saturated fatty acids that are stored in the form of triacylglycerides (TAGs). One of the major TAG species of cocoa butter, consisting of two stearic acid molecules and one oleic acid molecule (stearic acid-oleic acid-stearic acid, sn-SOS), is particularly rare in nature as the saturated fatty acid stearic acid is typically found only in low abundance. Demand for cocoa butter is increasing, yet T. cacao can only be cultivated in some parts of the tropics. Alternative means of production of cocoa butter lipids (CBLs) are, therefore, sought after. Yeasts also store fatty acids in the form of TAGs, but these are typically not rich in saturated fatty acids. To make yeast an attractive host for microbial production of CBLs, its fatty acid composition needs to be optimized. We engineered Saccharomyces cerevisiae yeast strains toward a modified fatty acid synthesis. Analysis of the fatty acid profile of the modified strains showed that the fatty acid content as well as the titers of saturated fatty acids and the titers of TAGs were increased. The relative content of potential CBLs in the TAG pool reached up to 22% in our engineered strains, which is a 5.8-fold increase over the wild-type. SOS content reached a level of 9.8% in our engineered strains, which is a 48-fold increase over the wild type.