Inactivation and Membrane Damage Mechanism of Slightly Acidic Electrolyzed Water on Pseudomonas deceptionensis CM2.

Pseudomonas is considered as the specific spoilage bacteria in meat and meat products. The purpose of this study was to evaluate the inactivation efficiency and mechanisms of slightly acidic electrolyzed water (SAEW) against Pseudomonas deceptionensis CM2, a strain isolated from spoiling chicken breast. SAEW caused time-dependent inactivation of P. deceptionensis CM2 cells. After exposure to SAEW (pH 5.9, oxidation-reduction potential of 945 mV, and 64 mg/L of available chlorine concentration) for 60 s, the bacterial populations were reduced by 5.14 log reduction from the initial load of 10.2 log10 CFU/mL. Morphological changes in P. deceptionensis CM2 cells were clearly observed through field emission-scanning electron microscopy as a consequence of SAEW treatment. SAEW treatment also resulted in significant increases in the extracellular proteins and nucleic acids, and the fluorescence intensities of propidium iodide and n-phenyl-1-napthylamine in P. deceptionensis CM2 cells, suggesting the disruption of cytoplasmic and outer membrane integrity. These findings show that SAEW is a promising antimicrobial agent.

Effects of slightly acidic electrolyzed water on the quality and antioxidant capacity of fresh red waxy corn during postharvest cold storage.

Fresh red waxy corn is consumed worldwide because of its unique flavor and rich nutrients, but it is susceptible to deterioration with a short shelf life. This study explored the effect of slightly acidic electrolyzed water (SAEW) treatment on the quality and antioxidant capacity of fresh red waxy corn during postharvest cold storage up to 40 d. The SAEW treatment exhibited lower weight loss, softer firmness, and higher total soluble solids (TSS) and moisture content than the control group. Correspondingly, the SAEW maintained the microstructure of endosperm cell wall and starch granules of fresh red waxy corn kernels well, contributing to good sensory quality. Furthermore, SAEW effectively reduced the accumulation of H2O2 content, elevated the O2 -· scavenging ability, maintained higher CAT and APX activities, and decreased the decline of the flavonoids and anthocyanin during the storage. These results revealed that the SAEW treatment could be a promising preservation method to maintain higher-quality attributes and the antioxidant capacity of fresh red waxy corn during postharvest cold storage.

Effect of Slightly Acidic Electrolyzed Water Immersion at Different Frequencies on Quality of Raw Chicken Legs.

Slightly acidic electrolyzed water (SAEW) is used as a disinfectant for raw chicken meat. Because its volume for a single immersion exceeds 10 times the weight of meat, a large amount of wastewater is generated. Importantly, a higher frequency of immersion is believed to reduce microbial contamination. The objective of this study was to investigate the effect of SAEW immersion at different frequencies on the disinfection and quality of raw chicken legs, thereby possibly limiting the usage of SAEW. Immersion for 1, 3, and 5 times, with a 7:1 SAEW:meat ratio, and duration of 15 min was tested. Meat quality was evaluated based on total aerobic bacteria, Enterobactericeae, total volatile basic nitrogen, thiobarbituric acid reactive substances, and color. A higher immersion frequency lowered the numbers of total aerobic bacteria and Enterobacteriaceae. Moreover, two immersions with a SAEW:meat ratio of 4:1 and a total immersion time of 6 min reduced the bacterial load as effectively as a single 15-min immersion with a SAEW:meat ratio of 7:1. Higher frequencies of SAEW immersion also resulted in lower total volatile basic nitrogen and lipid oxidation after 0 or 3 days of storage. They did, however, magnify the change in color, resulting in brighter meat. Overall, SAEW treatments with two to five immersions can improve the quality of raw chicken legs and reduce wastewater generation.

Hydrogen-Rich Water Treatment of Fresh-Cut Kiwifruit with Slightly Acidic Electrolytic Water: Influence on Antioxidant Metabolism and Cell Wall Stability.

The synergistic impact of hydrogen-rich water (HRW, 394 ppb) and slightly acidic electrolyzed water (SAEW, pH of 6.25 ± 0.19) on the antioxidant metabolism of fresh-cut kiwifruit during storage was investigated (temperature: (3 ± 1) °C, humidity: 80%-85%). Compared with control group, H+S treatment increased the contents of active oxygen-scavenging enzymes (SOD, CAT, POD, and APX) and inhibited the increase of O2•- and H2O2 contents during the storage of fresh-cut kiwifruit. Meanwhile, H+S treatment could reduce the activities of the cell wall-degrading enzymes PG, PME, PL, Cx, and ß-Gal, inhibit the formation of soluble pectin, delay the degradation rate of propectin, cellulose, and pseudocellulose, and maintain higher fruit hardness and chewability. The results showed that H+S treatment could enhance free radical scavenging ability and reduce the cell wall metabolism of fresh-cut kiwifruit, maintaining the good texture found in fresh-cut fruit.

Effect of Slightly Acidic Electrolyzed Water on Growth, Diarrhea and Intestinal Bacteria of Newly Weaned Piglets.

As an environmentally-friendly agent, slightly acidic electrolyzed water (SAEW) was introduced in drinking water of newly weaned piglets for diarrhea prevention. In total, 72 piglets were employed and 3% SAEW was added into the normal temperature and warm (30 °C) tap water, respectively, for this 33-day feeding experiment. It was found that the total bacteria and coliforms in the drinking water were reduced by 70% and 100%, respectively, with the addition of 3% SAEW. After SAEW treatment, the average daily water and feed intakes of piglets were increased during the first 16 days, and the diarrhea rate was reduced by 100%, with not one case of diarrhea recorded at the end of the experiment. The microbiome results demonstrated that SAEW decreased the diversity of caecum bacteria with normal tap water supplied, and increased the richness of the caecum bacteria with warm tap water supplied. SAEW also increased the abundance of potentially beneficial genera Sutterella and Ruminococcaceae_UCG-005 and reduced the abundance of pathogenic Faecalibacterium. Moreover, twelve metabolic functions belonging to the cluster of metabolism and organismal functions, including digestion and the endocrine and excretory systems, were greatly enhanced. Correlation analysis indicated that the influence of intestinal pathogens on water and feed intakes and the diarrhea of piglets were decreased by SAEW. The results suggest that SAEW can be used as an antibiotic substitute to prevent diarrhea in newly weaned piglets.

Stability and Antibiofilm Efficiency of Slightly Acidic Electrolyzed Water Against Mixed-Species of Listeria monocytogenes and Staphylococcus aureus.

In the natural environment, most microorganisms live in mixed-species biofilms, in which the metabolism and growth of organisms are different from that in single-species biofilms. Adhesive bacteria and their biofilms on the surface of food processing equipment are the sources of cross-contamination, leading to the risk for humans. Slightly acidic electrolyzed water (SAEW) has been proposed as a novel sanitizer in the food and agriculture industry. In this study, we investigated the changes in the physical properties of SAEW under different conditions and the disinfection abilities of SAEW against spore-forming and non-spore-forming pathogens. Furthermore, we examined the disinfection abilities of SAEW after 12 months of shelf life on a mixed-species biofilm of Listeria monocytogenes Scott A and Staphylococcus aureus. The results showed that SAEW at 30 and 50 ppm achieved all-kill of the spore-forming pathogen Bacillus cereus within 30 s. Changes in the ACC and pH of the produced SAEW were generally affected by the storage conditions. Both spore-forming and non-spore-forming pathogens were not detected under treatment with 50 ppm SAEW for 5 min under HDPE-closed conditions throughout the whole storage period. Moreover, 25 mg/L SAEW can inactivate L. monocytogenes Scott A and S. aureus biofilm cells in ~2.45 and 2.57 log CFU/mL in biofilms within 5-min treatment. However, the decline of the two bacteria in the mixed-species biofilm was 1.95 and 1.43 log CFU/mL, respectively. The changes in the cell membrane permeability of the mixed-species biofilm under treatment with SAEW were observed by using atomic force microscopy and confocal laser scanning microscopy. L. monocytogenes Scott A was more sensitive to SAEW in the mixed-species biofilm cells. These findings exhibited strong antibiofilm activities of SAEW in impairing biofilm cell membranes, decreasing cell density, and eliminating biofilm, which suggest that SAEW is an excellent antibacterial agent in the food processing industries.

Ultrasound-Assisted Slightly Acidic Electrolyzed Water in Aquatic Product Sterilization: A Review.

Ultrasound has been confirmed as the propagation process of mechanical vibrations in a medium, with a frequency significantly higher than 20 kHz. Moreover, it has an effect of sterilization on foods. In general, ultrasonic sterilization medium is manifested as a liquid. Ultrasonic treatment technology has certain advantages in aquatic product processing. It is noteworthy that this technology will have better effects of sterilization if used in combination with other treatment methods. Slightly acidic electrolyzed water (SAEW) is characterized by high-efficiency broad-spectrum sterilization operation, low cost, and environmental protection, among other properties, and has a positive effect on aquatic product sterilization and preservation. Selecting acidic electrolyzed water with a low concentration coupled with low-power ultrasonic waves for combined sterilization exerts a more potent sterilization effect, and acidic electrolyzed water combined with ultrasonic sterilization is expected to be a potentially environment-friendly alternative. In this study, the sterilization mechanisms of ultrasonic and SAEW methods used both individually and as a synergistic treatment, the effect on microbial growth, and the research progress of the application of the combined effect in the sterilization and refrigeration of aquatic products are reviewed. Furthermore, this study looks forward to the future development trend, with a view to its application in aquatic products, while providing a reference for research and application in the field of processing and safety.

Effects of Wheat Tempering with Slightly Acidic Electrolyzed Water on the Microbiota and Flour Characteristics.

Slightly acidic electrolyzed water (SAEW) was prepared and used as wheat tempering water. This study explored the impacts of tempering with SAEW on microbial load and diversity and quality properties of wheat flour. As SAEW volume ratio increased, the residual level of total plate counts (TPC) and mould/yeast counts (MYC) decreased dramatically (p < 0.05). Based on genomics analysis, bacterial 16S rRNA gene and fungal ITS1 gene region were performed to characterize the changes in microbial communities' composition and diversity in response to SAEW treatment. SAEW optimal volume ratio (6.5:10, v/v) of SAEW with distilled water influenced wheat microbiome composition, with a higher microbial diversity and abundance discovered on the control grains. Bacteroidetes of predominant bacterial phylum and Ascomycota of the most abundant fungal phylum were reduced after SAEW optimal volume ratio tempering. The flour yield is higher and ash content is lower than the control samples. Falling number and "b*" in terms of colour markedly increased. DSC (Differential Scanning Calorimetry) test showed that To (onset temperature), Tp (peak temperature), and Tc (conclusion temperature) were significantly decreased in thermal characteristics of flour. Gluten content, protein content, ΔH and pasting properties tests showed no significant change. It can be concluded that SAEW should be applied on wheat tempering for producing clean wheat flour. ANOVA and Tukey's honestly significant difference (HSD) test were used for the analysis of variance and differences between the experimental and control groups, with p < 0.05.

Kinetic Modeling of Slightly Acidic Electrolyzed Water Decay Characteristics in Fresh Cabbage Disinfection Against Human Norovirus.

To consistently disinfect fresh vegetables efficiently, the decay of disinfectants such as chlorine, electrolyzed oxidizing water (EOW), ozonated water, and plasma-activated water during the disinfection maintenance stage needs to be understood. The aim of our study was to evaluate the changes in the inactivation kinetics of slightly acidic electrolyzed water (SAEW) against human norovirus (HuNoV), based on the cabbage-to-SAEW ratio. After disinfection of fresh cabbage with disinfected SAEW solution, SAEW samples were collected and analyzed for physicochemical properties such as pH, available chlorine concentrations (ACCs), and oxidation-reduction potential (ORP). SAEW virucidal effects were evaluated. We confirmed the decay of post-disinfection SAEW solution and demonstrated the different patterns of the decay kinetic model for HuNoV GI.6 and GII.4. In addition, the goodness of fit of the tested models based on a lower Akaike information criterion, root-mean-square error (RMSE), and residual sum of squares (RSS) was close to zero. In particular, the change in both the HuNoV GI.6 and GII.4 inactivation exhibited a strong correlation with the changes in the ACC of post-disinfection SAEW. These findings demonstrate that physicochemical parameters of SAEW play a key role in influencing the kinetic behavior of changes in the disinfection efficiency of SAEW during the disinfection process. Therefore, to optimize the efficiency of SAEW, it is necessary to optimize the produce-to-SAEW ratio in future studies.

Effects of Combined Aerosolization with Ultraviolet C Light-Emitting Diode on Enterohemorrhagic Escherichia coli and Staphylococcus aureus Attached to Soft Fresh Produce.

Washing soft fresh produce such as strawberries, baby leaves, and sliced onions with sanitizing agents is challenging due to their fragile texture. Thus, treatments like aerosolization using slightly acidic electrolyzed water (SAEW) and ultraviolet C light-emitting diode (UVC LED) irradiation may be good alternatives. In the present study, the reduction effects of a combined treatment of aerosolization using SAEW and UVC LED irradiation on enterohemorrhagic Escherichia coli (EHEC) and Staphylococcus aureus attached to strawberries, baby leaves, and sliced onions were investigated. The behaviours of EHEC and S. aureus, moisture loss, colour measurement, and visual appearance were also analyzed at 10 and 15 °C for 7 days. The reduction effect of the combined treatment with 100 SAEW and UVC LED was higher (0.53-0.92 log CFU g-1) than a single aerosolization treatment (0.11-0.41 log CFU g-1), regardless of samples or pathogens. A greater effect on EHEC and S. aureus reduction was observed in strawberries (0.74 and 0.92 log CFU g-1) than in baby leaves (0.62 and 0.53 log CFU g-1) and sliced onions (0.55 and 0.62 log CFU g-1). The combined treatment further reduced the EHEC and S. aureus populations in strawberries during 7 days of storage at 10 and 15 °C. However, the EHEC and S. aureus populations were maintained in baby leaves and sliced onions at 10 °C for 7 days. Additionally, the greatest effect on the maintenance of colour and appearance was obtained in the combined treatment. Since the combined treatment reduces EHEC and S. aureus populations and preserves visual quality, it could be expected to extend the shelf life of soft fresh produce at the retailer stage of the supply chain.

Combined Hurdle Technologies Using UVC Waterproof LED for Inactivating Foodborne Pathogens on Fresh-Cut Fruits.

This study investigated the combined bactericidal efficacy of slightly acidic electrolyzed water (SAEW), fumaric acid (FA), and ultravioletC waterproof light-emitting diodes (UVC W-LED) for the control of Staphylococcus aureus and Listeria monocytogenes in fresh-cut fruits. Cherry tomato, grape, apple, and pineapple were inoculated with S. aureus and L. monocytogenes and then washed with 30 ppm SAEW containing 0.5% FA in a container equipped with two UVC W-LEDs. Behaviors of S. aureus and L. monocytogenes and quality properties of fresh-cut fruits were monitored after storage at 10 °C and 15 °C for 7 days. The most effective reductions of S. aureus (1.65 log CFU/g) and L. monocytogenes (2.63 log CFU/g) were observed in the group with the combined treatment of SAEW + FA and UVC W-LED. At 10 °C and 15 °C, populations of both pathogens in the combined treatment group were lower than those in a control. Combined treatment showed no negative effect on moisture retention in the fruit. Moreover, visual changes were less significant than in the control. These results demonstrate that the combined treatment can improve the microbial safety and the quality of fruits. If it is properly used in the sanitizing step of the fresh produce industry, a positive effect can be expected.

Control Measures of Pathogenic Microorganisms and Shelf-Life Extension of Fresh-Cut Vegetables.

We investigated the combined effect of using slightly acidic electrolyzed water (SAEW), ultrasounds (US), and ultraviolet-C light-emitting diodes (UV-C LED; 275 nm) for decreasing pathogenic Escherichia coli and Staphylococcus aureus (SEA) in fresh-cut vegetables, including carrots, celery, paprika, and cabbage. Survival of pathogenic E. coli and SEA and quality properties of fresh-cut vegetables at 5 and 15 °C for 7 days were also investigated. When combined treatment (SAEW + US + UV-C LED) was applied to fresh-cut vegetables for 3 min, its microbial reduction effect was significantly higher (0.97~2.17 log CFU/g) than a single treatment (p < 0.05). Overall, the reduction effect was more significant for SEA than for pathogenic E. coli. At 5 °C, SAEW + US and SAEW + US + UV-C LED treatments reduced populations of pathogenic E. coli and SEA in all vegetables. At 15 °C, SAEW + US + UV-C LED treatment inhibited the growth of both pathogens in carrot and celery and extended the shelf life of fresh-cut vegetables by preventing color changes in all vegetables. Although the effects of treatments varied depending on the characteristics of the vegetables and pathogens, UV-C LED can be suggested as a new hurdle technology in fresh-cut vegetable industry.

Slightly Acidic Electrolyzed Water Treatment Enhances the Main Bioactive Phytochemicals Content in Broccoli Sprouts via Changing Metabolism.

Changes in the content of bioactive phytochemicals in the broccoli sprouts subjected to different slightly acidic electrolyzed water (SAEW) treatments were investigated in the present study. The highest sulforaphane amount in broccoli sprouts treated with SAEW with an available chlorine concentration (ACC) of 50 mg/L was 11.49 mg/g in dry weight (DW), which increased by 61.2% compared to the control. SAEW treatment enhanced the sulforaphane content mainly by increasing the glucoraphanin (GRA) concentration due to the promotion of methionine metabolism and increased myrosinase activities. In addition, the relative anthocyanin contents of light-germinated broccoli under SAEW 50 treatment were 2.03 times that of broccoli sprouts with tap water treatment, and these contents were associated with an increase in phenylalanine ammonia lyase (PAL) activities and phenylalanine participation in biosynthesis. In summary, SAEW promotes metabolism to induce the accumulation of bioactive compounds in broccoli sprouts.