Simultaneous quantification of the most common and proteolytic Pseudomonas species in raw milk by multiplex qPCR.

The heat-stable peptidase AprX, secreted by psychrotolerant Pseudomonas species in raw milk, is a major cause of destabilization and premature spoilage of ultra-high temperature (UHT) milk and milk products. To enable rapid detection and quantification of seven frequent and proteolytic Pseudomonas species (P. proteolytica, P. gessardii, P. lactis, P. fluorescens, P. protegens, P. lundensis, and P. fragi) in raw milk, we developed two triplex qPCR assays taking into account species-dependent differences in AprX activity. Besides five species-specific hydrolysis probes, targeting the aprX gene, a universal rpoB probe was included in the assay to determine the total Pseudomonas counts. For all six probes, linear regression lines between Cq value and target DNA concentration were obtained in singleplex as well as in multiplex approaches, yielding R2 values of > 0.975 and amplification efficiencies of 85-97%. Moreover, high specificity was determined using genomic DNA of 75 Pseudomonas strains, assigned to 57 species, and 40 other bacterial species as templates in the qPCR. Quantification of the target species and total Pseudomonas counts resulted in linear detection ranges of approx. 103-107 cfu/ml, which correspond well to common Pseudomonas counts in raw milk. Application of the assay using 60 raw milk samples from different dairies showed good agreement of total Pseudomonas counts calculated by qPCR with cell counts derived from cultivation. Furthermore, a remarkably high variability regarding the species composition was observed for each milk sample, whereby P. lundensis and P. proteolytica/P. gessardii were the predominant species detected. KEY POINTS: • Multiplex qPCR for quantification of seven proteolytic Pseudomonas species and total Pseudomonas counts in raw milk • High specificity and sensitivity via hydrolysis probes against aprX and rpoB • Rapid method to determine Pseudomonas contamination in raw milk and predict spoilage potential.

An indirect ELISA system for the detection of heat-stable Pseudomonas endopeptidases (AprX) in milk.

Heat-stable endopeptidases in raw milk, especially the alkaline metallopeptidase AprX secreted by Pseudomonas spp., are a well-known challenge for the dairy industry. They can withstand UHT treatment and may cause quality defects over the shelf life of milk products. Therefore, we established an indirect ELISA for the detection of Pseudomonas AprX in milk. We developed a 2-step sample treatment for milk contaminated with AprX to avoid the interference of milk proteins with the detection system. First, casein micelles were destabilized by the detraction of Ca2+ using trisodium citrate; then, AprX was concentrated 10-fold using hydrophobic interaction chromatography. The recovery of AprX in spiked milk samples after the 2-step treatment was 43 ± 0.1%. Specific antibodies for purified AprX from Pseudomonas lactis were produced to establish the ELISA. Western blot experiments showed that the binding affinity of these antibodies depended on the sequence homology of the AprX from P. lactis and several other Pseudomonas spp. The indirect ELISA, which was completed in 6 to 7 h, had a limit of detection of 21.0 ng mL-1 and a limit of quantification of 25.7 ng mL-1. Milk proteins or milk endogenous peptidases were not detected by the antibodies. The ELISA had high precision, with a CV between 0.2 and 0.8% measured on the same day (intraday) and 5.6 and 6.8% measured on 5 separate days (interday). Milk samples were spiked with different AprX activity levels [7.5-150 nkat Na-caseinate/o-phthalaldehyde (OPA) mL-1] and evaluated by ELISA. The recovery of the ELISA was 92.3 ± 1.6 to 105 ± 4.7%. The lowest AprX activity quantifiable in the spiked milk samples was 500 pkat Na-caseinate/OPA mL-1. The proof of concept to detect heat-stable Pseudomonas AprX in milk by ELISA was established.

Stability of fat globules in UHT milk during proteolysis by the AprX protease from Pseudomonas fluorescens and by plasmin.

Fat separation is a limiting factor for the shelf life of UHT milk. It may be promoted by the proteolysis of fat surface-adsorbed proteins (FSAP) by proteases that remain active after UHT treatment. The aim of this research was to explore the relationship between the proteolysis of FSAP and fat destabilization. In this study, we developed a full-fat UHT milk-based model system and added either the major bacterial protease AprX from Pseudomonas fluorescens or the major native milk protease plasmin at high levels to induce fast destabilization of the milk fat globules. We monitored changes in physical properties and FSAP composition, and structural changes in fat globules, over 24 h. Our results showed that AprX-induced sedimentation as a result of the flocculation of fat globules, and plasmin induced cream to float as a result of the coalescence of fat globules. This study confirmed that AprX and plasmin can both lead to fat destabilization in full-fat UHT milk, and it provides insights in the underlying mechanisms.

Identification of Pseudomonas jessenii and Pseudomonas gessardii as the most proteolytic Pseudomonas isolates in Iranian raw milk and their impact on stability of sterilized milk during storage.

Identification of the most proteolytic Pseudomonas strains that can produce heat-resistant proteases and contribute to the Ultra High Temperature (UHT) milk destabilization is of great interest. In the present study, among the 146 Pseudomonas isolates that encoded the aprX gene, five isolates with the highest proteolytic activity were selected and identified based on 16S rRNA, rpoD and gyrB gene sequences data. The identification results were confirmed by phylogenetic analysis based on multilocus sequence analysis and identified the representative isolates as P. jessenii (two isolates) and P. gessardii (three isolates). Casein zymography demonstrated the ability of these species to produce heat-resistant enzymes, AprX, with molecular mass of about 48 kDa during storage at 7° C for 72 h. In sterilized milk samples, the residual activity of AprX caused a considerable enhancement in the degree of protein hydrolysis, non-protein nitrogen and non-casein nitrogen contents of the samples during a two-month storage. This enhancement was slightly higher in samples containing enzyme produced by P. jessenii compared to P. gessardii ones, resulting in earlier onset of sterilized milk destabilization. Hence, this study revealed that P. jessenii and P. gessardii can play a considerable role in deterioration of Iranian commercial long-life milk.

The Extracellular Protease AprX from Pseudomonas and its Spoilage Potential for UHT Milk: A Review.

The negative effects of proteases produced by psychrotrophic bacteria on dairy products, especially ultra-high-temperature (UHT) milk, are drawing increasing attention worldwide. These proteases are especially problematic, because it is difficult to control psychrotrophic bacteria during cold storage and to inactivate their heat-resistant proteases during dairy processing. The predominant psychrotrophic species with spoilage potential in raw milk, Pseudomonas, can produce a thermostable extracellular protease, AprX. A comprehensive understanding of AprX on the aspects of its biological properties, regulation, proteolytic potential, and its impact on UHT milk can contribute to finding effective approaches to minimize, detect, and inactivate AprX. AprX also deserves attention as a representative of all extracellular metalloproteases produced by psychrotrophic bacteria in milk. The progress of current research on AprX is summarized in this review, including a view on the gap in current understanding of this enzyme. Reducing the production and activity of AprX has considerable potential for alleviating the problems that arise from the instability of UHT milk during shelf-life.

Extracellular thermostable proteolytic activity of the milk spoilage bacterium Pseudomonas fluorescens PS19 on bovine caseins.

We studied the thermostable proteolytic activity of Pseudomonas fluorescens PS19 isolated from raw bovine milk. The heat-treated cell-free supernatant (HT-CFS) contained a thermostable protease of approximately 45 kDa, as revealed by casein zymography. We assigned this enzyme to P. fluorescens AprX metalloprotease (UniProtKB Acc. No. C9WKP6). After concentration by ultrafiltration at 10 kDa, the HT-CFS showed 2 other thermostable proteolytic bands on zymogram, with molecular masses of approximately 15 and 25 kDa. The former resulted a fragment of the AprX protease, whereas the 25-kDa protease was not homologous to any known protein of Pseudomonas spp. Subsequently, we assessed the proteolytic activity of the HT-CFS on bovine αS-, ß-, and κ-casein during in vitro incubation at 7 or 22°C. By means of ultra-performance liquid chromatography-tandem mass spectrometry we identified the released peptides (n=591). Some of them resisted proteolysis during the whole incubation period at both incubation temperatures and, therefore, they could be assumed as indicators of the proteolytic action of P. fluorescens PS19 on bovine caseins.

Post-translational secretion stress regulation in Bacillus subtilis is controlled by intra- and extracellular proteases.

The Gram-positive bacterium Bacillus subtilis is a prolific producer of industrial enzymes that are effectively harvested from the fermentation broth. However, the high capacity of B. subtilis for protein secretion has so far not been exploited to the full due to particular bottlenecks, including product degradation by extracellular proteases and counterproductive secretion stress responses. To unlock the Bacillus secretion pathway for difficult-to-produce proteins, various cellular interventions have been explored, including genome engineering. Our previous research has shown a superior performance of genome-reduced B. subtilis strains in the production of staphylococcal antigens compared to the parental strain 168. This was attributed, at least in part, to redirected secretion stress responses, including the presentation of elevated levels of the quality control proteases HtrA and HtrB that also catalyse protein folding. Here we show that this relates to the elimination of two homologous serine proteases, namely the cytosolic protease AprX and the extracellular protease AprE. This unprecedented posttranslational regulation of secretion stress effectors, like HtrA and HtrB, by the concerted action of cytosolic and extracellular proteases has important implications for the biotechnological application of microbial cell factories. In B. subtilis, this conclusion is underscored by extracellular degradation of the staphylococcal antigen IsaA by both AprX and AprE. Extracellular activity of the cytosolic protease AprX is remarkable since it shows that not only extracellular, but also intracellular proteases impact extracellular product levels. We therefore conclude that intracellular proteases represent new targets for improved recombinant protein production in microbial cell factories like B. subtilis.

Bioluminescence resonance energy transfer biosensor for measuring activity of a protease secreted by Pseudomonas fluorescens growing in milk.

Bacterial proteases are sporadic contributors to milk spoilage, reducing the quality of ultra-heat treated (UHT) milk and other dairy products. Current methods for measuring bacterial protease activity in milk are insensitive and too slow to be used in routine testing in dairy processing plants. We have designed a novel bioluminescence resonance energy transfer (BRET)-based biosensor to measure the activity of proteases secreted by bacteria in milk. The BRET-based biosensor is highly selective for bacterial protease activity compared with other proteases tested, notably including plasmin, which is abundant in milk. It incorporates a novel peptide linker that is selectively cleaved by P. fluorescens AprX proteases. The peptide linker is flanked by green fluorescent protein (GFP2) at the N-terminus and a variant Renilla luciferase (RLuc2) at the C-terminus. Complete cleavage of the linker by bacterial proteases from Pseudomonas fluorescens strain 65, leads to a 95% decrease in the BRET ratio. We applied an azocasein-based calibration method to the AprX biosensor using standard international enzyme activity units. In a 10-min assay, the detection limit for AprX protease activity in buffer was equivalent to 40 pg/mL (≈0.8 pM, 22 µU/mL) and 100 pg/mL (≈2pM, 54 µU/mL) in 50% (v/v) full fat milk. The EC50 values were 1.1 ± 0.3 ng/mL (87 µU/mL) and 6.8 ± 0.2 ng/mL (540 µU/mL), respectively. The biosensor was approximately 800x more sensitive than the established FITC-Casein method in a 2-h assay, the shortest feasible time for the latter method. The protease biosensor is sensitive and fast enough to be used in production settings. It is suitable for measuring bacterial protease activity in raw and processed milk, to inform efforts to mitigate the effects of heat-stable bacterial proteases and maximise the shelf-life of dairy products.

Development of a real-time loop-mediated isothermal amplification method for monitoring Pseudomonas lurida in raw milk throughout the year of pasture.

Introduction: The psychrophilic bacterium Pseudomonas lurida (P. lurida) and its thermostable alkaline proteases can seriously damage raw milk quality. Methods: In this study, specific primers were designed for P. lurida's gyrB and aprX genes, and a real-time loop-mediated isothermal amplification (RealAmp) rapid detection method was developed for the early monitoring of P. lurida and its proteases in raw milk. A phylogenetic tree of the gyrB and aprX genes of P. lurida was constructed to analyze the homology of the design sequence of the RealAmp primer. The DNA of 2 strains of P. lurida and 44 strains of non-P. lurida were detected via RealAmp to analyze the specificity of the primer. Results: It was found that aprX-positive proteases were produced by P. lurida-positive strains only when Pseudomonas fluorescens was negative. The dissociation temperatures of gyrB and aprX in the RealAmp-amplified products were approximately 85.0°C and 90.0°C, respectively. Moreover, DNA was detected through a 10-fold dilution of P. lurida in a pure bacterial solution and artificially contaminated skimmed milk. The limit of detection of P. lurida DNA copy number in the pure bacterial solution was 8.6 copies/µL and that in the 10% skimmed milk was 5.5 copies/µL. Further, 144 raw milk samples throughout the year from three farms in Hebei province were analyzed using RealAmp. The highest detection rate of P. lurida was 56% in the first and third quarters, and that of proteases was 36% in the second quarter. The detection rates of P. lurida and its proteases were the highest in samples collected from pasture 2 (52 and 46%, respectively), and the ability of P. lurida to produce proteases reached 88%. Discussion: In conclusion, RealAmp established an early and rapid method for the detection of P. lurida and its proteases in raw milk samples, allowing the identification and control of contamination sources in a timely manner to ensure the quality of milk and dairy products.

Rapid Identification of Pseudomonas fluorescens Harboring Thermostable Alkaline Protease by Real-Time Loop-Mediated Isothermal Amplification.

ABSTRACT: Thermostable alkaline protease (TAP) harbored by Pseudomonas fluorescens decomposes protein in milk and dairy products, leading to milk and dairy product spoilage during storage. Thus, a specific, sensitive, rapid, and simple method is required to detect TAP-harboring P. fluorescens. Two sets of primers targeting the aprX and gyrB genes of P. fluorescens were designed. The detection system and conditions were optimized, and a real-time loop-mediated isothermal amplification (real-time LAMP) method was developed for the simultaneous detection of TAP-harboring P. fluorescens in two separate reaction tubes. The phylogenetic tree targeting aprX showed that P. fluorescens and Pseudomonas lurida clustered on the same branch. The phylogenetic tree targeting gyrB showed that P. fluorescens clustered on the same branch with 95% confidence value, whereas P. lurida clustered on different branches. DNA of 16 strains of P. fluorescens and 34 strains of non-P. fluorescens was detected by real-time LAMP. TAP-harboring P. fluorescens can only be identified when the real-time LAMP detection results of both aprX and gyrB are positive. The dissociation temperatures of aprX and gyrB in the real-time LAMP-amplified products were approximately 90.0 and 88.0°C, respectively. The detection limits of the real-time LAMP targeting aprX and gyrB were 4.9 CFU per reaction in pure culture and 2.2 CFU per reaction in skimmed milk. The coefficient of variation of the repeatability test was less than 2%, indicating that the established real-time LAMP of P. fluorescens targeting gyrB and aprX has good stability and repeatability. Real-time LAMP was used to test 200 raw milk samples for the presence of TAP-harboring P. fluorescens in 3 h, and the coincidence rate of the results with those obtained using the traditional method, which takes at least 5 to 7 days, was 100%. Real-time LAMP will be a practical and effective method for accurate and rapid identification of TAP-harboring P. fluorescens in raw milk.

Proteolytic Traits of Psychrotrophic Bacteria Potentially Causative of Sterilized Milk Instability: Genotypic, Phenotypic and Peptidomic Insight.

The proteolytic traits of the psychrotrophic strains Pseudomonas poae LP5, Pseudomonas fluorescens LPF3, Chryseobacterium joostei LPR1, Pseudomonas fulva PS1, Citrobacter freundii PS37, Hafnia alvei PS46, and Serratia marcescens PS92 were initially investigated by phenotypic and genotypic approaches. Six strains elicited extracellular proteolytic activity, and five expressed the thermostable AprX or (likely) Ser1 enzymes. Then, the strains were inoculated (104 CFU/mL) in microfiltered pasteurized milk and kept at 4 °C for five days. All of the strains reached 108 CFU/mL at the end of storage and five produced thermostable extracellular proteolytic enzymes. The freshly inoculated samples and the corresponding samples at 108 CFU/mL were batch-sterilized (131 °C, 30 s) and kept at 45 °C up to 100 days. The former samples did not gel until the end of incubation, whereas the latter, containing P. poae, P. fluorescens, C. joostei, C. freundii, and S. marcescens, gelled within a few days of incubation. The thermostable proteolytic activity of strains affected the peptidomic profile, and specific proteolyzed zones of ß-CN were recognized in the gelled samples. Overall, the results confirm some proteolytic traits of psychrotrophic Pseudomonas spp. strains and provide additional insights on the proteolytic activity of psychrotrophic bacteria potentially responsible for sterilized milk destabilization.

Genetic Organization of the aprX-lipA2 Operon Affects the Proteolytic Potential of Pseudomonas Species in Milk.

Psychrotolerant Pseudomonas species are a main cause of proteolytic spoilage of ultra-high temperature (UHT) milk products due to the secretion of the heat-resistant metallopeptidase AprX, which is encoded by the first gene of the aprX-lipA2 operon. While the proteolytic property has been characterized for many different Pseudomonas isolates, the underlying aprX-lipA2 gene organization was only described for a few strains so far. In this study, the phylogenomic analysis of 185 Pseudomonas type strains revealed that the presence of aprX is strongly associated to a monophylum composed of 81 species, of which 83% carried the aprX locus. Furthermore, almost all type strains of known milk-relevant species were shown to be members of the three monophyletic groups P. fluorescens, P. gessardii, and P. fragi. In total, 22 different types of aprX-lipA2 genetic organizations were identified in the genus, whereby 31% of the species tested carried the type 1 operon structure consisting of eight genes (aprXIDEF prtAB lipA2). Other genetic structures differed from type 1 mainly in the presence and location of genes coding for two lipases (lipA1 and lipA2) and putative autotransporters (prtA and prtB). The peptidase activity of 129 strains, as determined on skim milk agar and in UHT-milk, correlated largely with different aprX-lipA2 gene compositions. Particularly, isolates harboring the type 1 operon were highly proteolytic, while strains with other operon types, especially ones lacking prtA and prtB, exhibited significantly lower peptidase activities. In conclusion, the phylogenomic position and the aprX-lipA2 gene organization specify the proteolytic potential of Pseudomonas isolates. In addition, however, an interplay of several environmental factors and intrinsic traits influences production and activity of AprX, leading to strain-specific proteolytic phenotypes.

Bacterial proteolysis of casein leading to UHT milk gelation: An applicative study.

Heat-stable peptidases released in refrigerated raw milk by psychrotrophic bacteria are responsible for UHT milk gelation. K-casein-derived caseinomacropeptides, identified by mass spectrometry, were constantly detected in gelled milk by capillary electrophoresis. Strains of Pseudomonas fluorescens, Ps. poae and Chryseobacterium joostei, selected among aprX-positive strains from raw milk, were incubated in milk up to 6 days at 4 °C before sterilization (98 °C/4 min). Samples were then stored at 25 or 40 °C, visually observed for gelation, and analysed for presence of caseinomacropeptides throughout 90 days of storage. Depending on cold pre-incubation time, caseinomacropeptides accumulated well before gelation onset in milk stored at 25 °C. Caseinomacropeptides were successively degraded, especially in milk stored at 40 °C, due to extensive proteolysis, and an abundant sediment developed instead of a gel. The caseinomacropeptides are here presented as an early indicator of UHT milk gelation and a mechanism explaining this phenomenon is proposed.

Two Heat Resistant Endopeptidases from Pseudomonas Species with Destabilizing Potential during Milk Storage.

In the current study, the extracellular endopeptidases from Pseudomonas lundensis and Pseudomonas proteolytica were investigated. The amino acid sequence identity between both endopeptidases is 68%. Both endopeptidases were purified to homogeneity and partially characterized. They were classified as metallopeptidases with a maximum activity at pH 10.0 ( P. lundensis) or 8.5 ( P. proteolytica) at 35 °C. Both remained active in skim milk with 39.7 ± 2.4% and 24.5 ± 3.3%, respectively, of the initial enzyme activity after UHT processing (138 °C for 20 s), indicating the relevance for milk destabilization. The transition points in buffer were determined at 50 °C ( P. lundensis) and 43 °C ( P. proteolytica) using circular dichroism spectroscopy. The loss of the secondary structure at different temperatures was correlated with residual peptidase activities after heat treatment. The ability to destabilize UHT milk was proven by supplementation of skim milk with endopeptidase and storage for 4 weeks.

Destabilization of UHT milk by protease AprX from Pseudomonas fluorescens and plasmin.

Destabilization of UHT milk during its shelf life is mainly promoted by the residual proteolytic activity attributed to the psychrotrophic bacterial proteases and native milk proteases. In this study, we built skim UHT milk-based model systems to which either the major bacterial protease (AprX from Pseudomonas fluorescens), or the major native milk protease (plasmin) was added, to allow a direct comparison between the destabilization of skim UHT milk by both categories of enzymes. The physical and chemical properties were studied during 6 weeks. Our results showed AprX induced compact gels when almost all the κ-casein was hydrolyzed and the degree of hydrolysis (DH) exceeded 1.3%. Plasmin induced soft gels when around 60% of both ß- and αs1-casein were hydrolyzed and the DH reached 2.1%. The knowledge gained from this study may be used for developing diagnostic tests for determining the protease responsible for UHT milk destabilisation.

Characterization of Pseudomonas spp. and Associated Proteolytic Properties in Raw Milk Stored at Low Temperatures.

Milk spoilage is caused by the presence of proteolytic enzymes produced by Pseudomonas spp. during storage at low temperatures. The aim of this study was to identify Pseudomonas spp. in raw milk and investigate their associated proteolytic properties at low temperatures. Raw milk samples (n = 87) were collected from 87 bulk tanks in Shaanxi Province in China. Pseudomonas spp. were identified using Pseudomonas specific 16S, universal 16S rRNA sequencing, and rpoB gene sequencing. The proteolytic properties of Pseudomonas spp. were examined using milk agar, quantitative trinitrobenzenesulfonic acid assay, and by the presence of alkaline metallopeptidase gene (aprX). A total 143 isolates from all 87 samples were confirmed as Pseudomonas, and were identified as belonging to 14 Pseudomonas species. Of these, 40 (28.0%) isolates revealed proteolysis on milk agar at 2°C, 74 (51.8%) at 4°C, 104 (72.7%) at 7°C, and 102 (71.3%) at 10°C. However, proteolytic activity of 45 (31.5%) isolates exceeded 2 µmol of glycine equivalents per mL at 7°C, followed by 43 (30.1%) at 10°C, 18 (12.6%) at 4°C, and 7 (4.9%) at 2°C. The results reveal proteolytic activity of Pseudomonas spp. present in milk and their spoilage potential at different temperatures.

Characterisation of the Thermostable Protease AprX in Strains of Pseudomonas Fluorescens and Impact on the Shelf-life of Dairy Products: Preliminary Results.

Bacterial proteases are involved in food spoilage and shelf-life reduction. Among the bacterial proteases, a predominant role in spoilage of dairy products seems to be played by the thermostable metallo-protease AprX, which is produced by various strains of Pseudomonas fluorescens. Differences in AprX enzyme activity among different strains were highlighted, but the most proteolytic strains were not identified. In this study, the presence of the aprX gene was evaluated in 69 strains isolated from food matrices and 18 reference strains belonging to the P. fluorescens group, which had been previously typed by the multi locus sequence typing method. Subsequently, a subset of reference strains was inoculated in ultra-high temperature milk, and the expression of the aprX gene was evaluated at 22 and 6°C. On the same milk samples, the proteolytic activity was then evaluated through Azocasein and trinitrobenzenesulfonic acid solution assays. Finally, to assess the applicability of the former assay directly on dairy products the proteolityc activity was tested on industrial ricotta samples using the Azocasein assay. These results demonstrate the spread of aprX gene in most strains tested and the applicability of Azocasein assay to monitor the proteolytic activity in dairy products.

Characterization of Gram-negative psychrotrophic bacteria isolated from Italian bulk tank milk.

Eighty psychrotrophic bacterial strains, isolated from different northwest Italian bulk tank milks destined for Grana Padano cheese production, were identified by 16S rRNA gene amplification and partial sequence analysis of the rpoB gene. Pseudomonas spp. were the most commonly occurring contaminants, P. fluorescens being the predominant isolated species, along with Enterobacteriaceae, primarily Serratia marcescens. RAPD-PCR was used to study genetic variability and distinguish closely related strains; a high degree of genetic heterogeneity among the strains was highlighted. All the strains were characterized for their ability to produce proteases, lipases and lecithinases at different temperatures (7, 22, and 30 °C). Forty-one of the psychrotrophic strains were positive for all the enzymatic activities. The highest number of positive strains for all the incubation temperatures was found for lipolytic activity (59), followed by proteolytic (31) and lecithinase (28) activities, and the enzymatic traits varied among the Pseudomonas and Enterobacteriaceae strains. The proteolytic psychrotrophic strains were screened for the presence of the aprX gene, coding for a heat-resistant metalloprotease in Pseudomonas spp. The aprX gene was detected in 19 of 63 Pseudomonas strains, and was widespread in the P. fluorescens strains (14/19). PRATICAL APPLICATION: The study provides new data on the enzymatic activity of Gram-negative psychrotrophic bacteria, useful in developing strategies to control the proteo-lipolytic spoilage of raw and processed milk that causes gelation, off-flavors, and loss of sensory quality and shelf life.

Pseudomonas spp. and other psychrotrophic microorganisms in inspected and non-inspected Brazilian Minas Frescal cheese: proteolytic, lipolytic and AprX production potential / Pseudomonas spp. e outros micro-organismos psicrotróficos em queijos Minas Frescal inspecionados e não inspecionados: potencial proteolítico, lipolítico e produção de AprX

The most consumed cheese in Brazil, Minas Frescal cheese (MFC) is highly susceptible to microbial contamination and clandestine production and commercialization can pose a risk to consumer health. The storage of this fresh product under refrigeration, although more appropriate, may favor the growth of spoilage psychrotrophic bacteria. The objective of this study was to quantify and compare Pseudomonas spp. and other psychrotrophic bacteria in inspected and non-inspected MFC samples, evaluate their lipolytic and proteolytic activities and their metalloprotease production potentials. Twenty MFC samples were evaluated: 10 inspected and 10 non-inspected. Counts of psychrotrophic bacteria and Pseudomonas spp., evaluation of the proteolytic and lipolytic potential of the isolates, and identification of potential producers of alkaline metalloprotease (AprX) were assessed. The mean total psychrotrophic counts were 1.07 (±2.18) × 109CFU/g in the inspected samples and 4.5 (±5.86) × 108CFU/g in the non-inspected, with no significant difference (p=0.37). The average score of Pseudomonas spp. was 6.86 (±18.6) × 105 and 2.08 (±3.65) × 106 CFU/g for the inspected and non-inspected MFC samples, respectively, with no significant difference (p=0.1). Pseudomonas spp. represented 0.06% and 0.004% of psychrotrophic bacteria found in inspected and non-inspected MFC samples, respectively. Collectively, 694 psychrotrophic strains and 47Pseudomonas spp. were isolated, of which 59.9% and 68.1% were simultaneously proteolytic and lipolytic, respectively. Of the 470 psychrotrophs isolated from inspected and 224 from non-inspected cheese samples, 5.74% and 2.23% contained aprX, respectively, while 100 and 86.96% of the Pseudomonas spp. isolates in inspected and non-inspected cheese samples contained the gene. The production potential of AprX did not, however, determine the proteolytic activity on plates of these isolates under the conditions evaluated in this study. Of total, 65.63% of the psychrotrophs that contained aprX gene were confirmed as Pseudomonas spp., using genus-specific PCR. Phylogenetic analysis of the 16S rRNA gene of the other psychrotrophs that were potential producers of AprX identified them as Serratia spp. (n=7), Raoultella ornithinolytica (n=1), and Acinetobacter schindleri (n=1) in the inspected samples and Psychrobacter sanguinis (n=1) and Leuconostoc mesenteroides (n=1) in the non-inspected samples. The production conditions of Brazilian MFC of these samples, while meeting the legal determinations, are not sufficient to control Pseudomonas and other spoilage-related psychrotrophs. Thus, stricter hygienic measures are required during the formal production of this type of cheese.(AU)

O mais consumido no Brasil, o queijo Minas Frescal (QMF) é altamente suscetível à contaminação microbiana e a produção e comercialização clandestina podem representar um risco para a saúde do consumidor. O armazenamento deste produto fresco sob refrigeração, embora mais apropriado, pode favorecer a multiplicação de bactérias psicrotróficas deteriorantes. O objetivo deste estudo foi quantificar e comparar Pseudomonas spp. e outras bactérias psicrotróficas em amostras de QMF inspecionadas e não inspecionadas, avaliar o potencial lipolítico, proteolítico e de produção de metaloprotease alcalina. Vinte amostras de QMF foram avaliadas: 10 inspecionadas e 10 não inspecionadas. Foram avaliadas as contagens de bactérias psicrotróficas e Pseudomonas spp., o potencial proteolítico e lipolítico dos isolados e a identificação de potenciais produtores de metaloprotease alcalina (AprX). A média total das contagens de bactérias psicrotróficas foi de 1,07 (±2,18) × 109UFC/g nas amostras inspecionadas e 4,5 (±5,86) × 108UFC/g nas não inspecionadas, sem diferença significativa (p=0,37). A média de Pseudomonasspp. foi de 6,86 (±18,6) × 105 e 2,08 (±3,65) × 106UFC/g para as amostras QMF inspecionadas e não-inspecionadas, respectivamente, sem diferença significativa (p=0,1). Pseudomonas spp. representaram 0,06% e 0,004% de bactérias psicrotróficas encontradas em amostras QMF inspecionadas e não-inspecionadas, respectivamente. Das amostras inspecionadas e não inspecionadas, foram isoladas 694 colônias psicrotróficas e 47 Pseudomonasspp., dos quais 59,9% e 68,1% foram simultaneamente proteolíticos e lipolíticos, respectivamente. Dos 470 isolados de psicrotróficos das amostras de queijo inspecionados e dos 224 isolados das não inspecionadas, 5,74% e 2,23% continham o gene aprX, respectivamente, enquanto 100 e 86,96% das Pseudomonasspp. isoladas em amostras de queijo inspecionadas e não inspecionadas continham o potencial de expressão de AprX. Esse potencial, no entanto, não determinou a atividade proteolítica em placas desses isolados nas condições avaliadas neste estudo. Do total, 65,63% dos psicrotróficos que continham o gene aprX foram confirmados como Pseudomonasspp., utilizando PCR gênero-específico. A análise filogenética do gene 16S rRNA dos outros psicrotróficos que foram produtores potenciais de AprX os identificou como Serratia spp. (n=7), Raoultella ornithinolytica (n=1) e Acinetobacter schindleri (n=1) nas amostras inspecionadas e Psychrobacter sanguinis (n=1) e Leuconostoc mesenteroides (n=1) nas amostras não inspecionadas. As condições de produção do QMF dessas amostras, atendendo às determinações legais, não são suficientes para controlar a Pseudomonas e outros psicrotróficos relacionados à deterioração. Assim, medidas higiênicas mais rígidas são necessárias durante a produção formal deste tipo de queijo.(AU)