Pressurized Liquid Extraction (PLE) as an Innovative Green Technology for the Effective Enrichment of Galician Algae Extracts with High Quality Fatty Acids and Antimicrobial and Antioxidant Properties.

Marine organisms are potentially prolific sources of high qualify fatty acids that represent useful leads in the development of new nutraceutical agents. In this work, we investigated the lipid composition of six algae species from the Northwest of Spain (Ulva intestinalis, Ulva lactuca, Fucus vesiculosus,Dictyota dichotoma, Cystoseira baccata and Himanthalia elongata) and compared the antioxidant and antibacterial activity of ethanolic extracts obtained by pressurized liquid extraction (PLE). Furthermore, Fucus vesiculosus (F. vesiculosus) PLE using five solvents of different polarities (hexane, ethyl acetate, acetone, ethanol and ethanol:water 50:50) at three temperatures (80 °C, 120 °C and 160 °C) was investigated. F. vesiculosus ethanolic PLE extract presents considerably higher capacity of inhibiting 50% of DPPH (1,1-diphenyl-2-picryl hydrazyl) (IC50 = 7.17 μg/mL) in comparison with the rest of macroalgae studied. Moreover, the potential antimicrobial activity tested on E. coli and S. aureus shows that F. vesiculosus extract produced the best inhibition (IC50 was 2.24 mg/mL (E. coli) and 1.27 mg/mL (S. aureus)). Furthermore, regarding the different solvents and temperatures used to investigate F. vesiculosus PLE, results showed that this technique using ethyl acetate is a selective method to enrich long chain fatty acids (oleic acid, arachidonic acid and eicosapentaenoic acid) with ω-6/ω-3 ratios close to 2.7.

Biological Activities of Asteraceae (Achillea millefolium and Calendula officinalis) and Lamiaceae (Melissa officinalis and Origanum majorana) Plant Extracts.

Asteraceae (Achillea millefolium and Calendula officinalis) and Lamiaceae (Melissa officinalis and Origanum majorana) extracts were obtained by applying two sequential extraction processes: supercritical fluid extraction with carbon dioxide, followed by ultrasonic assisted extraction using green solvents (ethanol and ethanol:water 50:50). The extracts were analyzed in terms of the total content of phenolic compounds and the content of flavonoids; the volatile oil composition of supercritical extracts was analyzed by gas chromatography and the antioxidant capacity and cell toxicity was determined. Lamiaceae plant extracts presented higher content of phenolics (and flavonoids) than Asteraceae extracts. Regardless of the species studied, the supercritical extracts presented the lowest antioxidant activity and the ethanol:water extracts offered the largest, following the order Origanum majorana > Melissa officinalis ≈ Achillea millefolium > Calendula officinalis. However, concerning the effect on cell toxicity, Asteraceae (especially Achillea millefolium) supercritical extracts were significantly more efficient despite being the less active as an antioxidant agent. These results indicate that the effect on cell viability is not related to the antioxidant activity of the extracts.

Extraction of functional ingredients from spinach (Spinacia oleracea L.) using liquid solvent and supercritical CO2 extraction.

BACKGROUND: In this work three different techniques were applied to extract dry leaves of spinach (Spinacia oleracea): solid-liquid extraction (SLE), pressurised liquid extraction (PLE) and supercritical fluid extraction (SFE) to investigate the influence of extraction solvent and technique on extracts composition and antioxidant activity. Moreover, the influence of carotenoids and phenolic compounds on the antioxidant and anti-inflammatory activities of spinach extracts was also studied. RESULTS: The higher concentrations of carotenoids and the lower content of phenolic compounds were observed in the supercritical CO2 extracts; whereas water and/or ethanol PLE extracts presented low amounts of carotenoids and the higher concentrations of phenolic compounds. PLE extract with the highest content of phenolic compounds showed the highest antioxidant activity, although SFE carotenoid rich extract also showed a high antioxidant activity. Moreover, both extracts presented an important anti-inflammatory activity. CONCLUSION: PLE seems to be a good technique for the extraction of antioxidant and anti-inflammatory compounds from spinach leaves. Moreover, spinach phenolic compounds and carotenoids present a high antioxidant activity, whereas spinach carotenoids seem to show a higher anti-inflammatory activity than phenolic compounds. It is worth noting that of our knowledge this is the first time the anti-inflammatory activity of lipophilic extracts from spinach leaves is reported.

Modulation of estrogen and epidermal growth factor receptors by rosemary extract in breast cancer cells.

Breast cancer is the leading cause of cancer-related mortality among females worldwide, and therefore the development of new therapeutic approaches is still needed. Rosemary (Rosmarinus officinalis L.) extract possesses antitumor properties against tumor cells from several organs, including breast. However, in order to apply it as a complementary therapeutic agent in breast cancer, more information is needed regarding the sensitivity of the different breast tumor subtypes and its effect in combination with the currently used chemotherapy. Here, we analyzed the antitumor activities of a supercritical fluid rosemary extract (SFRE) in different breast cancer cells, and used a genomic approach to explore its effect on the modulation of ER-α and HER2 signaling pathways, the most important mitogen pathways related to breast cancer progression. We found that SFRE exerts antitumor activity against breast cancer cells from different tumor subtypes and the downregulation of ER-α and HER2 receptors by SFRE might be involved in its antitumor effect against estrogen-dependent (ER+) and HER2 overexpressing (HER2+) breast cancer subtypes. Moreover, SFRE significantly enhanced the effect of breast cancer chemotherapy (tamoxifen, trastuzumab, and paclitaxel). Overall, our results support the potential utility of SFRE as a complementary approach in breast cancer therapy.

Antitumor effect of 5-fluorouracil is enhanced by rosemary extract in both drug sensitive and resistant colon cancer cells.

5-Fluorouracil (5-FU) is the most used chemotherapeutic agent in colorectal cancer. However, resistance to this drug is relatively frequent, and new strategies to overcome it are urgently needed. The aim of this work was to determine the antitumor properties of a supercritical fluid rosemary extract (SFRE), alone and in combination with 5-FU, as a potential adjuvant therapy useful for colon cancer patients. This extract has been recognized as a healthy component by the European Food Safety Authority (EFSA). The effects of SFRE both alone and in combination with 5-FU were evaluated in different human colon cancer cells in terms of cell viability, cytotoxicity, and cell transformation. Additionally, colon cancer cells resistant to 5-FU were used to assay the effects of SFRE on drug resistance. Finally, qRT-PCR was performed to ascertain the mechanism by which SFRE potentiates the effect of 5-FU. Our results show that SFRE displays dose-dependent antitumor activities and exerts a synergistic effect in combination with 5-FU on colon cancer cells. Furthermore, SFRE sensitizes 5-FU-resistant cells to the therapeutic activity of this drug, constituting a beneficial agent against both 5-FU sensitive and resistant tumor cells. Gene expression analysis indicates that the enhancement of the effect of 5-FU by SFRE might be explained by the downregulation of TYMS and TK1, enzymes related to 5-FU resistance.

Evaluation of the interrelated effects of slaughtering, drying, and defatting methods on the composition and properties of black soldier fly (Hermetia illucens) larvae fat.

The interrelated effect of different slaughtering, drying and defatting methods of black soldier fly larvae (BSFL) on the lipid composition and properties of the fat was studied. Blanching and freezing were compared as slaughtering methods, oven or freeze-drying as drying methods, and mechanical pressing or supercritical fluid extraction (SFE) as defatting methods. The different modes of slaughtering, drying, and defatting, along with both binary and ternary interactions caused significant effects on processes yields, lipid composition, moisture content and thermal properties. Thus, considering the defatting degree and the yield in total valued products (defatted meal plus fat), the combination of blanching, freeze-drying plus mechanical pressing was the worst option (51.2% and 87.5%, respectively). In contrast, the other combinations demonstrated better and comparable efficiency, although SFE is preferable for defatting (83.2% and 96.9%, respectively). The content of major fatty acids (lauric, palmitic and myristic acids) was significantly affected by the BSFL treatments, although with unsignificant impact on the total saturated fatty acids content. To preserve the integrity of the fat, the combination of blanching and oven-drying was preferred, as non-thermal methods of slaughtering and drying caused intense lipolysis, releasing free fatty acids (FFA) in the range of 18.6-23.5%. To achieve the lowest moisture content in the fats (≤0.1%), oven-drying with mechanical pressing were desired, regardless of the slaughtering method; while values > 1% were reached for freezing, freeze-drying and SFE. Both differences in FFA and moisture contents caused different thermal behaviors in the samples. Specially, the melting temperature was lower for samples with higher FFA and moisture contents, with a notable difference when freezing, freeze-drying and SFE were combined (14.5 °C vs 30.6 °C, as the mean value for the rest of samples). The different modes of processing did not affect the minor lipid compounds. Therefore, the modes employed for slaughtering, drying, and defatting of BSFL determine, either individually or in combination, the process yields, composition, and properties of the fat.

The Interaction of Slaughtering, Drying, and Defatting Methods Differently Affects Oxidative Quality of the Fat from Black Soldier Fly (Hermetia illucens) Larvae.

The interrelation effect of slaughtering, drying, and defatting methods of BSFL on the oxidative quality of the derived fat was studied. Blanching and freezing were compared as slaughtering methods, followed by oven or freeze-drying for drying and mechanical pressing or SFE for defatting. The oxidative state and stability of the extracted fat and defatted meals were monitored immediately after their production, using peroxide value (PV) and Rancimat test, and over 24 weeks of storage. Slaughtering and drying methods had an independent effect on PV, with freezing and freeze-drying being the best methods. Mechanical pressing and SFE were comparable and superior to conventional hexane defatting. Interactions were observed between slaughtering and defatting, drying and defatting, and between all three factors. Generally, freeze-drying combined with any of the slaughtering and defatting methods resulted in the lowest PVs, with mechanical pressing being preferred. Freeze-drying plus mechanical pressing also produced the most stable fats during storage according to the evolution of PV, while the combination of blanching and SFE produced the least stable. A significant correlation was found between the PV at 24 weeks and the antioxidant activity of the fats. Contrary to storage assays, in accelerated Rancimat assays, freeze-dried samples were the least stable, which was partially attributed to the significant correlation with the acid values of the samples. Defatted meals followed a similar pattern to the extracted fat, except for worse oxidation for SFE defatting. Therefore, the different processing methods of slaughtering, drying, and defatting of BSFL differently affect lipid oxidation, with interactions between such successive steps.

Resazurin-based high-throughput screening method for the discovery of dietary phytochemicals to target microbial transformation of L-carnitine into trimethylamine, a gut metabolite associated with cardiovascular disease.

Nowadays, there is great interest in the discovery of food compounds that might inhibit gut microbial TMA production from its methylamine precursors. In this work, an innovative novel screening strategy capable of rapidly determining the differences in the metabolic response of Klebsiella pneumoniae, a bacteria producing TMA under aerobic conditions, to a library of extracts obtained from food and natural sources was developed. The proposed high-throughput screening (HTS) method combines resazurin reduction assay in 384-well plates and Gaussian Processes as a machine learning tool for data processing, allowing for a fast, cheap and highly standardized evaluation of any interfering effect of a given compound or extract on the microbial metabolism sustained by L-carnitine utilization. As a proof-of-concept of this strategy, a pilot screening of 39 extracts and 6 pure compounds was performed to search for potential candidates that could inhibit in vitro TMA formation from L-carnitine. Among all the extracts tested, three of them were selected as candidates to interfere with TMA formation. Subsequent in vitro assays confirmed the potential of oregano and red thyme hexane extracts (at 1 mg mL-1) to inhibit TMA formation in bacterial lysates. In such in vitro assay, the red thyme extract exerted comparable effects on TMA reduction (∼40%) as 7.5 mM meldonium (∼50% TMA decrease), a reported L-carnitine analogue. Our results show that metabolic activity could be used as a proxy of the capacity to produce TMA under controlled culture conditions using L-carnitine to sustain metabolism.

Effects of a Mealworm (Tenebrio molitor) Extract on Metabolic Syndrome-Related Pathologies: In Vitro Insulin Sensitivity, Inflammatory Response, Hypolipidemic Activity and Oxidative Stress.

The mealworm (Tenebrio molitor Linnaeus 1758) is gaining importance as one of the most popular edible insects. Studies focusing on its bioactivities are increasing, although alternative forms of consumption other than the whole insect or flour, such as bioactive non-protein extracts, remain underexplored. Furthermore, the incidence of metabolic syndrome-related pathologies keeps increasing, hence the importance of seeking novel natural sources for reducing the impact of certain risk factors. The aim was to study the potential of a non-protein mealworm extract on metabolic syndrome-related pathologies, obtained with ethanol:water (1:1, v/v) by ultrasound-assisted extraction. We characterized the extract by gas-chromatography mass-spectrometry and assessed its hypolipidemic potential, its ability to scavenger free radicals, to attenuate the inflammatory response in microglial cells, to affect mitochondrial respiration and to enhance insulin sensitivity in mouse hepatocytes. The extract contained fatty acids, monoglycerides, amino acids, certain acids and sugars. The mealworm extract caused a 30% pancreatic lipase inhibition, 80% DPPH· scavenging activity and 55.9% reduction in the bioaccessibility of cholesterol (p = 0.009). The extract was effective in decreasing iNOS levels, increasing basal, maximal and ATP coupled respiration as well as enhancing insulin-mediated AKT phosphorylation at low insulin concentrations (p < 0.05). The potential of a non-protein bioactive mealworm extract against metabolic syndrome-related pathologies is shown, although further studies are needed to elucidate the mechanisms and relationship with compounds.

Application of pressurized liquid extraction (PLE) to obtain bioactive fatty acids and phenols from Laminaria ochroleuca collected in Galicia (NW Spain).

The increase of pathologies like cardiovascular diseases, obesity or diabetes due to the nature of diet is a matter of concern in our society. Because of this, there is a high interest in healthy natural products that could prevent the appearance of such diseases. This paper aims to study the content of fatty acids (FAs) and phenolic compounds of brown alga Laminaria ochroleuca (L. ochroleuca) and to determine the nutritional quality of the lipids extracted using pressurized liquids extraction (PLE) technique. PLE was applied to the algae using four solvents of different polarity (hexane, ethyl acetate, ethanol and ethanol:water 1:1). Results showed that the higher yield (52%), is obtained with ethanol: water solvent, however, both ethyl acetate and ethanol enrich unsaturated fatty acid (USFA) (palmitoleic, linolenic, linoleic, oleic, araquidonic and eicosapenataenoic) in the lipid fraction of L. ochroleuca, providing extracts up to 55% of their total fatty acid content compared to other solvents. The nutritional quality of the lipids in all PLE extracts was assessed by considering the ω-6/ ω-3 fatty acid ratio and two dietary indexes involved in the risks of coronary heart disease, atherogenic (AI) and thrombogenic (TI). The lower (best) index values are for ethanol extract, 4.4 (ω-6/ ω-3), 0.74 (AI) and 1.05 (TI), followed of ethyl acetate, 4.4 (ω-6/ ω-3), 0.87 (AI) and 1.24 (TI). Finally, the antioxidant capacity of PLE alga extracts in terms of total phenol content (TPC) was analyzed by the Folin-Ciocalteu method. The ethanol: water extracts showed the highest TPC with a concentration up to 173.65 mg eq. gallic acid / g PLE extract.

Acute oral safety study of rosemary extracts in rats.

Increasing interest in rosemary plants is due to their antioxidant and health-enhancing properties. The aim of this study was to evaluate the potential acute toxicity of two supercritical fluid extracts of rosemary. An acute safety study of rosemary extracts was conducted in Wistar rats at a single oral gavage dosage of 2,000 mg/kg of body weight. Rosemary extracts were well tolerated; no adverse effects or mortality were observed during the 2-week observation period. No abnormal signs, behavioral changes, body weight changes, or change in food and water consumption occurred. Two weeks after a single oral rosemary extract dose of 2,000 mg/kg of body weight, there were no changes in hematological and serum chemistry values, organ weights, or gross or histological characteristics. Rosemary extracts appear to have low acute toxicity, and the oral lethal doses (LD50) for male and female rats are greater than 2,000 mg/kg of body weight.

Ultrasound-assisted extraction and bioaccessibility of saponins from edible seeds: quinoa, lentil, fenugreek, soybean and lupin.

The efficient production of saponin-rich extracts is of increasing interest due to the bioactive properties that have being demonstrated for these compounds. However, saponins have a poor bioavailability. In this respect, the knowledge about the bioaccessibility of saponins as a first step before bioavailability has been scarcely explored. In this study, the production of ultrasound-assisted extracts of saponins from edible seeds (quinoa, soybean, red lentil, fenugreek and lupin) was carried out with ethanol, ethanol:water or water. Extraction yield, total saponin (TSC), fat and total phenolics content (TPC) were determined. Then, the bioaccessibility of saponins after the in vitro gastrointestinal digestion of the extracts was determined and the effect of TPC and fat in the extracts on bioaccessibility was evaluated. The highest saponin-rich extracts were obtained by ethanol, being fenugreek and red lentil the richest extracts (12% and 10%, respectively). Saponins from ethanol:water extracts displayed variable bioaccessibility (from 13% for fenugreek to 83% for lentil), but a bioaccessibility closer to 100% was reached for all ethanol extracts. Correlation studies showed that TPC of the extracts negatively affected the bioaccessibility of saponins, whereas fat of the extracts enhanced this parameter. As summary, ultrasound-assisted extraction is shown as an efficient method for obtaining saponin-rich extracts from edible seeds, being ethanol the most advantageous solvent due to the richness of saponins and the successful bioaccessibility from these extracts, likely caused by the co-extracted fat with ethanol. Regardless of the extracts, phenolic compounds or fat may hinder or enhance the bioaccessibility of saponins, respectively. Additionally, an adequate balance between saponins to lipids has shown to be relevant on such an effect.

Use of specially designed columns for antioxidants and antimicrobials enrichment by preparative supercritical fluid chromatography.

A new, specially designed column has been developed for fractionation of supercritical fluid extract of rosemary by using a preparative supercritical fluid chromatography system (Prep-SFC). The column evaluated in this work was prepared using a new packing method consisting of a combination of slurry and supercritical CO2 with commercial silica particles coated with a stationary phase commonly used in gas chromatography, such as SE-54 (5% phenyl-, 95% methylsilicone). The new packing procedure provided columns with reasonable efficiencies, with high stability and useful at high-pressure range. A 25 cm x 10 mm i.d. column packed with silica particles coated with 3% of SE-54 was prepared, and its separation power was tested for isolating fractions with high antioxidant and/or antimicrobial activity from a supercritical rosemary extract. The SFC conditions were selected based on a previous work done with a commercial LC-Diol packed column (130 bar, 80 degrees C), and different percentages of modifier in the mobile phase were tested (5 and 10%). Two cyclones were employed to collect the fractions which were then characterized by HPLC-diode array detection (DAD), GC, and in vitro antioxidant and antimicrobial assays. The use of coated packed columns allowed the fractionation of a complex mixture of rosemary supercritical extract with a minimum amount of modifier in the mobile phase (5% ethanol). At the optimum conditions it was possible to obtain two very active fractions in terms of antioxidant and antimicrobial activity, with no residual rosemary aroma and with improved activities compared to the original supercritical extract.

Isolation of functional ingredients from rosemary by preparative-supercritical fluid chromatography (Prep-SFC).

A supercritical fluid extract of rosemary has been fractionated under supercritical conditions by using a preparative-SFC system. In this work, the optimum conditions have been evaluated to achieve a selective isolation of the compounds responsible for both, antioxidant and antimicrobial activities. A 25 cm x 10 mm i.d. LC-Diol packed column (dp=5 microm) has been used and the separation took place at 80 degrees C of column temperature, 130 bar of pressure, and 10% of ethanol as modifier of the mobile phase (CO(2)). Two cyclones were employed to collect the fractions which were subsequently characterized by HPLC-DAD, GC, and in vitro antioxidant and antimicrobial assays. By a careful selection of the separation conditions it is possible to obtain two different fractions, one enriched with antioxidant and antimicrobial compounds (with an improvement of about 20% and 40% of antioxidant and antimicrobial activity, respectively, compared to the original extract) collected in cyclone 2 and with no residual rosemary aroma and another one containing the essential oil.

Expression of microRNA-15b and the glycosyltransferase GCNT3 correlates with antitumor efficacy of Rosemary diterpenes in colon and pancreatic cancer.

Colorectal and pancreatic cancers remain important contributors to cancer mortality burden and, therefore, new therapeutic approaches are urgently needed. Rosemary (Rosmarinus officinalis L.) extracts and its components have been reported as natural potent antiproliferative agents against cancer cells. However, to potentially apply rosemary as a complementary approach for cancer therapy, additional information regarding the most effective composition, its antitumor effect in vivo and its main molecular mediators is still needed. In this work, five carnosic acid-rich supercritical rosemary extracts with different chemical compositions have been assayed for their antitumor activity both in vivo (in nude mice) and in vitro against colon and pancreatic cancer cells. We found that the antitumor effect of carnosic acid together with carnosol was higher than the sum of their effects separately, which supports the use of the rosemary extract as a whole. In addition, gene and microRNA expression analyses have been performed to ascertain its antitumor mechanism, revealing that up-regulation of the metabolic-related gene GCNT3 and down-regulation of its potential epigenetic modulator miR-15b correlate with the antitumor effect of rosemary. Moreover, plasmatic miR-15b down-regulation was detected after in vivo treatment with rosemary. Our results support the use of carnosic acid-rich rosemary extract as a complementary approach in colon and pancreatic cancer and indicate that GCNT3 expression may be involved in its antitumor mechanism and that miR-15b might be used as a non-invasive biomarker to monitor rosemary anticancer effect.

Isolation of carnosic acid from rosemary extracts using semi-preparative supercritical fluid chromatography.

Supercritical fluid chromatography (SFC) in analytical and semi-preparative scale was studied to separate rosemary (Rosmarinus officinalis) supercritical extracts to produce fractions with high antioxidant activity. Carnosic acid, the major antioxidant present in rosemary supercritical extracts, was the target compound to be isolated in the fractions produced. First, rosemary extracts were produced in a supercritical CO2 pilot-plant employing different extraction conditions, in order to obtain samples with diverse composition. The content of carnosic acid was determined and the DPPH test was accomplished in order to assess the antioxidant activity of the different samples produced. Then, using some of these samples, experiments were carried out in a semi-preparative SFC system testing the performance of four different chromatographic columns to isolate and recover a fraction with high concentration of carnosic acid. The four chromatographic columns employed were silica and 2-ethylpyridine (especially packed for SFC) and silica and diol columns (packed for HPLC). The SFC fractionation conditions explored were in the ranges 10-20 MPa, 313-333 K and 5-20% of cosolvent (ethanol). Using the first three columns, it was possible to isolate fractions with concentrations of carnosic acid greater than 80% mass.

Acute and repeated dose (28 days) oral safety studies of ALIBIRD in rats.

ALIBIRD, a test substance composed of oligosaccharides derived from lactulose, a hydrolysate of a whey protein concentrate, and a supercritical extract of rosemary (1:0.5:0.05), was prepared in the laboratory and evaluated for its safety as a multifunctional food additive. In oral toxicity studies (acute and 28 days repeated dose) using Wistar rats, ALIBIRD was administered in a single oral gavage dose of 2,000 mg/kg of body weight and resulted in no adverse events or mortality; a daily dose of 2,000 mg/kg of body weight for 28 days by gavage also resulted in no adverse effects or mortality. No abnormal clinical signs, behavioral changes, body weight changes, or changes in food and water consumption occurred in either study. There were no changes in hematological and serum chemistry values, organ weights, or gross or histological characteristics. Based on test results, it is concluded that ALIBIRD is well tolerated in rats at an acute and subchronic (28 days) dose of 2,000 mg/kg of body weight.

Supercritical carbon dioxide extraction of antioxidants from rosemary (Rosmarinus officinalis) leaves for use in edible vegetable oils.

Supercritical extraction was employed to produce rosemary (Rosmarinus officinalis L.) extracts with different composition and antioxidant activity. CO2 was utilized as supercritical solvent and diverse extraction conditions (temperature, pressure, amount of cosolvent and fractionation scheme) were applied. The extracts with higher antioxidant content were selected to study their capability as natural antioxidant of several commercial edible vegetable oils. Linseed oil (LO), grape seed oil (GO) and sesame oil (SO) were oxidized under Rancimat conditions in presence of 0, 100, 200 and 300 mg/kg of selected extracts. Antioxidant activity index (AAI) was estimated as the ratio of induction time in presence of extracts to induction time in absence of extract. Induction time in absence of extracts was 3.3, 7.9 and 23.4 h for LO, GO and SO, respectively. Regardless of these different susceptibilities, the highest AAI for the three oils was obtained for the extract with the highest antioxidant-enrichment (33.25% carnosic acid plus carnosol) and added at the highest level (300 mg/kg). However, at such conditions, the AAI was significantly higher (p<0.001) for LO (3.5), followed by SO (2.2) and the poorest value was for GO (1.1). Therefore, the magnitude of the AAI depended on the antioxidant-enrichment of the extracts, the level of addition within the oils, but also on the own individual oils.

Isolation of essential oil from different plants and herbs by supercritical fluid extraction.

Supercritical fluid extraction (SFE) is an innovative, clean and environmental friendly technology with particular interest for the extraction of essential oil from plants and herbs. Supercritical CO(2) is selective, there is no associated waste treatment of a toxic solvent, and extraction times are moderate. Further, supercritical extracts were often recognized of superior quality when compared with those produced by hydro-distillation or liquid-solid extraction. This review provides a comprehensive and updated discussion of the developments and applications of SFE in the isolation of essential oils from plant matrices. SFE is normally performed with pure CO(2) or using a cosolvent; fractionation of the extract is commonly accomplished in order to isolate the volatile oil compounds from other co-extracted substances. In this review the effect of pressure, temperature and cosolvent on the extraction and fractionation procedure is discussed. Additionally, a comparison of the extraction yield and composition of the essential oil of several plants and herbs from Lamiaceae family, namely oregano, sage, thyme, rosemary, basil, marjoram and marigold, which were produced in our supercritical pilot-plant device, is presented and discussed.

Testing and enhancing the in vitro bioaccessibility and bioavailability of Rosmarinus officinalis extracts with a high level of antioxidant abietanes.

An antioxidant-enriched extract (RE) was obtained from rosemary (Rosmarinus officinalis) by supercritical fluid extraction to be used as an ingredient to design functional foods. The optimized mixture (42 mg RE g(-1) sunflower oil) was submitted to in vitro digestion and absorption tests (using Caco2 cells) to investigate the effect of these processes on its DPPH scavenging activity and also whether its major abietanes (tricyclic diterpenes) might be bioaccessible and bioavailable. Results indicated that supplementation of the rosemary extract with sunflower oil and lecithin (37 mg g(-1)) enhanced abietanes micellation (almost 2-fold). In vitro digestion of the mixture including RE, sunflower oil, and lecithin reduced 50% the bioaccesibility in terms of antioxidant activity. Bioavailability was 31%. It was evidenced that this activity was not due to the original levels of carnosol, carnosic acid, and methyl carnosate (which only 47% remained after digestion) but due to their derivatives and digestion products.