Effects of protein composition and enzymatic activity on formation and properties of potato protein stabilized emulsions.

In the present study emulsions were made with various potato protein preparations, which varied in protease inhibitor and patatin content. These emulsions were characterized with respect to average droplet size, plateau surface excess, and the occurrence of droplet aggregation. Droplet aggregation occurred only with potato protein preparations that contained a substantial amount of protease inhibitors and could be prevented only at pH 3. The average droplet size of the emulsions made with potato proteins appeared to be related to the patatin content of the preparation used. Average droplet size was found to be dominated by the patatin-catalyzed lipolytic release of surface active fatty acids and monoglycerides from the tricaprylin oil phase during the emulsification process. Addition of monoglycerides and especially fatty acids, at concentrations representative of those during emulsification, was shown to cause a stronger and much faster decrease of the interfacial tension than that with protein alone and to result in a drastic decrease in droplet size. The patatin used was shown to have a lipolytic activity of 820 units/g with emulsified tricaprylin as the substrate. Because of the droplet aggregating properties of the protease inhibitors, the patatin-rich potato preparations seem to be the most promising for food emulsion applications over a broad pH range, provided the lipolytic activity can be diminished or circumvented.

Expanded bed adsorption as a fast technique for the large-scale purification of the complete isoform pool of Ber e 1, the major allergen from Brazil nuts.

A new, fast, large-scale purification method for Ber e 1, the major allergen from Brazil nuts, using expanded bed adsorption (EBA) chromatography, is presented. Using EBA, crude extracts can be applied to a fluidized column, which allows the unhindered passage of particulate impurities, thereby avoiding time-consuming centrifugation or filtration steps. With this new purification method, 2.8 g of Ber e 1 was obtained from 85 g defatted Brazil nut meal, essentially within 1 day. Various structural as well as immunochemical characteristics of the purified protein were determined, and compared to those of Ber e 1 purified using conventional chromatographic techniques. The complete pool of Ber e 1 isoforms was collected using EBA. The most abundant isoforms were observed to have pI around 8 and heterogeneity was observed in both the large and the small subunit of the heterodimeric protein. Ber e 1 has a highly ordered secondary structure. No apparent differences in immune reactivity were observed between EBA purified Ber e 1 and conventionally purified Ber e 1, using IgE-binding experiments. Thus, using EBA, Ber e 1 can be purified fast and on gram-scale, while having purity equal to that of conventionally purified Ber e 1.

Formation and stability of foams made with sunflower (Helianthus annuus) proteins.

Foam properties of a sunflower isolate (SI), as well as those of helianthinin and sunflower albumins (SFAs), were studied at various pH values and ionic strengths and after heat treatment. Less foam could be formed from helianthinin than from SFAs, but foam prepared with helianthinin was more stable against Ostwald ripening and drainage than foam prepared with SFAs. Foams made with SFAs suffered from extensive coalescence. The formation and stability of foams made from reconstituted mixtures of both proteins and from SI showed the deteriorating effect of SFAs on foam stability. Foam stability against Ostwald ripening increased after acid and heat treatment of helianthinin. Partial unfolding of sunflower proteins, resulting in increased structural flexibility, improved protein performance at the air/water interface. Furthermore, it was observed that the protein available is used inefficiently and that typically only approximately 20% of the protein present is incorporated in the foam.

Enzymatic hydrolysis as a means of expanding the cold gelation conditions of soy proteins.

Acid-induced cold gelation of soy protein hydrolysates was studied. Hydrolysates with degrees of hydrolysis (DH) of up to 10% were prepared by using subtilisin Carlsberg. The enzyme was inhibited to uncouple the hydrolysis from the subsequent gelation; the latter was induced by the addition of glucono-delta-lactone. Visual observations, confocal scanning laser microscopy images, and the elasticity modulus showed that hydrolysates gelled at higher pH values with increasing DH. The nonhydrolyzed soy protein isolate gelled at pH approximately 6.0, whereas a DH = 5% hydrolysate gelled at pH approximately 7.6. Gels made from hydrolysates had a softer texture when manually disrupted and showed syneresis below a pH of 5-5.5. Monitoring of gelation by measuring the development of the storage modulus could be replaced by measuring the pH onset of aggregate formation (pH(Aggr-onset)) using turbidity measurements. The rate of acidification was observed to also influence this pH(Aggr-onset). Changes in ionic strength (0.03, 0.2, and 0.5 M) had only a minor influence on the pH(Aggr-onset), indicating that the aggregation is not simply a balance between repulsive electrostatic and attractive hydrophobic interactions, but is much more complex.

Conformational states of sunflower (Helianthus annuus) Helianthinin: effect of heat and pH.

The structure and solubility of helianthinin, the most abundant protein of sunflower seeds, was investigated as a function of pH and temperature. Dissociation of the 11S form (hexamer) into the 7S form (trimer) gradually increased with increasing pH from 5.8 to 9.0. High ionic strength (I = 250 mM) stabilizes the 11S form at pH > 7.0. Heating and low pH resulted in dissociation into the monomeric constituents (2-3S). Next, the 7S and 11S forms of helianthinin were isolated and shown to differ in their secondary and tertiary structure, and to have denaturation temperatures (T(d)) of 65 and 90 degrees C, respectively. Furthermore, the existence of two populations of the monomeric form of helianthinin with denaturation temperatures of 65 and 90 degrees C was described. This leads to the hypothesis that helianthinin can adopt two different conformational states: one with T(d) = 65 degrees C and a second with T(d) = 90 degrees C.

Structural characterization of potato protease inhibitor I (Cv. Bintje) after expression in Pichia pastoris.

In the present study the structural properties of potato protease inhibitor 1 (PI-1) were studied as a function of temperature to elucidate its precipitation mechanism upon heating. A cDNA coding for PI-1 from cv. Bintje was cloned and expressed in Pichia pastoris. Using the recombinant PI-1 it was suggested that PI-1 behaves as a hexameric protein rather than as a pentamer, as previously proposed in the literature. The recombinant protein seems either to have a predominantly unordered structure or to belong to the beta-II proteins. Differential scanning calorimetry analysis of PI-1 revealed that its thermal unfolding occurs via one endothermic transition in which the hexameric PI-1 probably unfolds, having a dimer instead of a monomer as cooperative unit. The transition temperature for the recombinant PI-1 was 88 degrees C. Similar results were obtained for a partially purified pool of native PI-1 from cv. Bintje.

Tentative assignment of the potato serine protease inhibitor group as beta-II proteins based on their spectroscopic characteristics.

Potato serine protease inhibitor (PSPI) is the most abundant protease inhibitor group in potato tuber. The investigated PSPI isoforms have a highly similar structure at both the secondary and the tertiary level. From the results described, PSPI is classified as a beta-II protein based on (1) the presence in the near-UV spectra of sharp peaks, indicating a rigid and compact protein; (2) the sharp transition from the native to the unfolded state upon heating (only 6 degrees C) monitored by a circular dichroism signal at 222 nm; and (3) the similarity in secondary structure to soybean trypsin inhibitor, a known beta-II protein, as indicated by a similar far-UV CD spectrum and a similar amide I band in the IR spectrum. The conformation of PSPI was shown also to be stable at ambient temperature in the pH range 4-7.5. Upon lowering the pH to 3.0, some minor changes in the protein core occur, as observed from the increase of the intensity of the phenylalanine peak in the near-UV CD spectrum.

The most abundant protease inhibitor in potato tuber (cv. Elkana) is a serine protease inhibitor from the Kunitz family.

The gene of the most abundant protease inhibitor in potato cv. Elkana was isolated and sequenced. The deduced amino acid sequence of this gene showed 98% identity with potato serine protease inhibitor (PSPI), a member of the Kunitz family. Therefore, the most abundant protease inhibitor was considered to be one of the isoforms of PSPI. The PSPI group represents approximately 22% of the total amount of proteins in potato cv. Elkana and is composed of seven different isoforms that slightly differ in isoelectric point. Antibodies were raised against the two most abundant isoforms of PSPI. The binding of these antibodies to PSPI isoforms and protease inhibitors from different groups of protease inhibitor in potato showed that approximately 70% of the protease inhibitors present in potato juice belong to the Kunitz family.

Effects of non-covalent interactions with 5-O-caffeoylquinic acid (chlorogenic acid) on the heat denaturation and solubility of globular proteins.

The non-covalent interactions between the monomeric phenolic compound chlorogenic acid (5-CQA) and bovine serum albumin (BSA), lysozyme, and alpha-lactalbumin were characterized, and their effect on protein properties was examined. 5-CQA had a low affinity for all three proteins, and these interactions seemed to show a negative cooperativity. 5-CQA-BSA binding decreased with increasing temperature, whereas pH (pH 3.0 compared to pH 7.0) and ionic strength had no pronounced effect. At high 5-CQA/protein molar ratios, both the denaturation enthalpy and temperature of BSA increased; however, covalent bonds were created at high temperatures. The presence of 5-CQA had no effect on the solubility of BSA and alpha-lactalbumin as a function of pH, whereas it decreased lysozyme solubility at alkaline pH due to covalent interactions. These results indicate that the non-covalent interactions with 5-CQA do not have pronounced effects on the functional properties of globular proteins in food systems.

Formation and stability of foam made with various potato protein preparations.

In the present study, foam-forming and -stabilizing properties of potato proteins were studied using whipping and sparging tests. The soluble potato proteins are mainly composed of patatin and protease inhibitors. The whipping tests showed that less foam was formed from untreated patatin than from the protease inhibitors, but patatin foam was much more stable. The foam-forming properties of patatin could be strongly improved by partial unfolding of the protein. Whipping tests, at both low (0.5 mg/mL) and high (10 mg/mL) protein concentration, also indicated that foams made with an ethanol-precipitated protein isolate were more stable than those made with beta-casein and beta-lactoglobulin. More generally, it can be concluded that when proteins are used as a foaming agent, a high concentration is required, because the protein available is inefficiently used. Also, there are several variables that may all, in different ways, affect both foam formation (amount of foam, bubbles size distribution) and foam stability. These variables include the type and concentration of protein, solvent conditions (pH, I), and the method used to make the foam.

Effects of ethanol on structure and solubility of potato proteins and the effects of its presence during the preparation of a protein isolate.

In this study, a protein isolate with a high solubility at neutral pH was prepared from industrial potato juice by precipitation at pH 5 in the presence of ethanol. The effects of ethanol itself and the effects of its presence during precipitation on the properties of various potato protein fractions were examined. The presence of ethanol significantly reduced the denaturation temperature of potato proteins, indicating that the preparation of this potato protein isolate should be performed at low temperature in order to retain a high solubility. In the presence of ethanol, the thermal unfolding of the tertiary and the secondary structure of patatin was shown to be almost completely independent. Even at 4 degrees C, precipitation of potato proteins in the presence of ethanol induced significant conformational changes. These changes did, however, only result in minor changes in the solubility of the potato protein fractions as a function of pH and heat treatment temperature.

Effect of heat-induced aggregation on the IgE binding of patatin (Sol t 1) is dominated by other potato proteins.

The interaction of the major potato allergen patatin, Sol t 1, with IgE was investigated on a quantitative level as a function of heat treatment at different temperatures. On the basis of a number of publications, potato is considered to be a heat-labile allergen, but the molecular explanation for this behavior was not given. In this work, heat treatment of patatin in the absence and presence of other potato proteins mimicking the proteinaceous environment of the potato was studied. Using far-UV circular dichrosim spectroscopy, tryptophan fluorescence spectroscopy, and differential scanning calorimetry, the molecular transitions during heating of patatin were investigated. It was found that as long as patatin is not aggregated, denaturation of patatin on a secondary or tertiairy folding level is reversible with only a minor effect on the IgE affinity. Aggregation of patatin results in a nonreversible unfolding and a concomitant important decrease in affinity for IgE (25-fold). Aggregation of patatin in the presence of other potato proteins results in a less condensed aggregate compared to the situation of isolated patatin, resulting in a more pronounced decrease of affinity for IgE (110-fold). It is concluded that the heat lability of patatin-IgE interaction is explained by aggregation of patatin with other potato proteins rather than by denaturation of patatin itself.

Isolation and characterization of undenatured chlorogenic acid free sunflower (Helianthus annuus) proteins.

A method for obtaining sunflower protein (SFP) isolate, nondenatured and free of chlorogenic acid (CGA), has been developed. During the isolating procedure, the extent of CGA removal and protein denaturation was monitored. The defatted flour contained 2.5% CGA as the main phenolic compound. Phenolic compounds were removed by aqueous methanol (80%) extraction, before protein extraction at alkaline pH and diafiltration. Differential scanning calorimetry and solubility tests indicated that no denaturation of the proteins had occurred. The resulting protein products were biochemically characterized, and the presence of protein-CGA complexes was investigated. SFPs of the studied variety were found to be composed of two main protein fractions: 2S albumins and 11S globulins. In contrast to what has been previously reported, CGA was found to elute as free CGA, not covalently associated to any protein fraction.