Ultrasound induced grain refinement of crystallization in evaporative saline droplets.

We investigate the effect of ultrasound on the evaporation and crystallization of sessile NaCl solution droplets which were positioned in traveling or standing wave ultrasound field. The experimental results indicated that the ultrasound field can significantly accelerate the evaporation rate of the sessile droplets and refine the crystal grains. By adjusting the distance between the sessile droplets and the ultrasound emitter, it is found that, in traveling wave ultrasound field, the sessile droplet evaporation time and the time for the appearance of NaCl grains exhibited a fluctuating increase as the droplet-emitter distance increased. While in the standing wave ultrasound, the sessile droplet evaporation rate increases with the increasing droplet-emitter distance. Overall, the traveling wave ultrasound field has a stronger effect on grain refinement of the sessile droplets than the standing wave ultrasound field. The grain refinement is attributed to the decrease of critical nucleation radius caused by ultrasound energy and the increase of the nucleation rate caused by the accelerated evaporation rate. In addition, the breakage of grains caused by ultrasonic cavitation would also lead to grain refinement.

Newly Designed 3D-Printed Sonication Test Cell Optimized for In Vitro Sonication Experiments.

OBJECTIVE: Precise control over the ultrasound field parameters experienced by biological samples during sonication experiments in vitro may be quite challenging. The main goal of this work was to outline an approach to construction of sonication test cells that would minimize the interaction between the test cells and ultrasound. METHODS: Optimal dimensions of the test cell were determined through measurements conducted in a water sonication tank using 3D-printed test objects. The offset of local acoustic intensity variability inside the sonication test cell was set to value of ±50% of the reference value (i.e., local acoustic intensity measured at last axial maximum in the free-field condition). The cytotoxicity of several materials used for 3D printing was determined using the MTT (3-[4,5-dimethylthiazol-2-yl]-2,5 diphenyl tetrazolium bromide) assay. RESULTS: The sonication test cells were 3D printed from polylactic acid material, which was not toxic to the cells. Silicone membrane HT-6240, which was used to construct the bottom of the test cell, was found to reduce ultrasound energy minimally. Final ultrasound profiles inside the sonication test cells indicated the desired variability of local acoustic intensity. The cell viability in our sonication test cell was comparable to that of commercial culture plates with bottoms constructed with silicone membrane. CONCLUSION: An approach to construction of sonication test cells minimizing the interaction of the test cell and ultrasound has been outlined.

A survey on the stabilizing effect of osmolytes on the ultrasound-irradiated lipase for efficient enzymatic hydrolysis of coconut oil.

The stabilizing effect of some osmolytes including betaine, mannitol, proline, sorbitol, and trehalose (each 0.5 M) was investigated on the ultrasound-irradiated (60 kHz and 138 W, for 240 min) lipase by determination of the enzyme half-life time, evaluation of the enzymatic reaction velocity (Vmax), and hydrolysis of coconut oil for production of lauric acid (the main saturated fatty acid of the oil). The enzyme conformational stability was also assessed by circular dichroism (CD) and fluorescence spectroscopy. The average half-life time of mannitol- and sorbitol-treated lipase under the ultrasound irradiation was 511 ± 3 min and 531 ± 2 min, respectively; 3-fold higher than the unirradiated enzyme. The Vmax value of the ultrasound-treated lipase increased from 100 ± 3 nmol min-1 in the absence of osmolyte to 500 ± 7 nmol min-1 and 500 ± 9 nmol min-1 in the presence of mannitol and sorbitol, respectively. CD and fluorescence spectra indicated that mannitol and sorbitol enhanced the rigidity of the lipase molecular conformational structure, increasing the enzyme stability against the ultrasonic field. The ultrasound-irradiated lipase was then used to hydrolyze coconut oil in the absence or presence of the selected osmolytes, which led to liberate 310 ± 6 mg g-1, 413 ± 7 mg g-1, and 420 ± 4 mg g-1 of lauric acid in the absence or presence of sorbitol and mannitol, respectively. In the absence of an ultrasonic field, the non-osmotically-treated lipase was able to liberate only 211 ± 5 mg g-1 of lauric acid. These promising results indicate that sorbitol and mannitol stabilize the structural conformation of lipase under an ultrasonic field which in turn could improve the enzymatic hydrolysis of coconut oil.

Novel Animal Model of Spontaneous Cerebral Petechial Hemorrhage Using Focused Ultrasound in Rats.

Background and Objectives: Petechial cerebral hemorrhages can be caused by various factors, such as traumas, cerebral infarctions, and aging, and is related to the disruption of the blood-brain barrier or the cellular damage of blood vessels. However, there is no animal model that recapitulates cerebral petechial hemorrhages. Materials and Methods: Here, we implemented a petechial hemorrhage using a novel technology, i.e., microbubble-assisted focused ultrasound (MB + FUS). Results: This method increases the permeability of the blood-brain barrier by directly applying mechanical force to the vascular endothelial cells through cavitation of the microbubbles. Microbubble-enhanced cavitation has the advantage of controlling the degree and location of petechial hemorrhages. Conclusions: We thus generated a preclinical rat model using noninvasive focal MB + FUS. This method is histologically similar to actual petechial hemorrhages of the brain and allows the achievement of a physiologically resembling petechial hemorrhage. In the future, this method shall be considered as a useful animal model for studying the pathophysiology and treatment of petechial cerebral hemorrhages.

Verification of Blood-Brain Barrier Disruption Based on the Clinical Validation Platform Using a Rat Model with Human Skull.

Methods to improve drug delivery efficiency through blood-brain barrier disruption (BBBD) based on microbubbles and focused ultrasound (FUS) are continuously being studied. However, most studies are being conducted in preclinical trial environments using small animals. The use of the human skull shows differences between the clinical and preclinical trials. BBBD results from preclinical trials are difficult to represent in clinical trials because various distortions of ultrasound by the human skull are excluded in the former. Therefore, in our study, a clinical validation platform based on a preclinical trial environment, using a human skull fragment and a rat model, was developed to induce BBBD under conditions similar to clinical trials. For this, a human skull fragment was inserted between the rat head and a 250 kHz FUS transducer, and optimal ultrasound parameters for the free field (without human skull fragment) and human skull (with human skull fragment) were derived by 300 mVpp and 700 mVpp, respectively. BBBD was analyzed according to each case using magnetic resonance images, Evans blue dye, cavitation, and histology. Although it was confirmed using magnetic resonance images and Evans blue dye that a BBB opening was induced in each case, multiple BBB openings were observed in the brain tissues. This phenomenon was analyzed by numerical simulation, and it was confirmed to be due to standing waves owing to the small skull size of the rat model. The stable cavitation doses (SCDh and SCDu) in the human skull decreased by 13.6- and 5.3-fold, respectively, compared to those in the free field. Additionally, the inertial cavitation dose in the human skull decreased by 1.05-fold compared to that of the free field. For the histological analysis, although some extravasated red blood cells were observed in each case, it was evaluated as recoverable based on our previous study results. Therefore, our proposed platform can help deduct optimal ultrasound parameters and BBBD results for clinical trials in the preclinical trials with small animals because it considers variables relevant to the human skull.

Flow boiling heat transfer enhancement under ultrasound field in minichannel heat sinks.

The enhancement of the heat transfer assisted by ultrasound is considered to be an interesting and highly efficient cooling technology, but the investigation and application of ultrasound in minichannel heat sinks to strengthen the flow boiling heat transfer are very limited. Herein, a novel installation of ultrasound transducers in the flow direction of a minichannel heat sink is designed to experimentally study the characteristics of heat transfer in flow boiling and the influence of operation parameters (e.g., heat flux, mass flux rate) and ultrasound parameters (e.g., frequency, power) on the flow boiling heat transfer in a minichannel heat sink with and without ultrasound field. Bubble motion and flow pattern in the minichannel are analyzed by high-speed flow visualization, revealing that the ultrasound field induces more bubbles at the same observation position and a forward shift of the onset of nucleation boiling along the flow direction, as ultrasonic cavitation produces a large number of bubbles. Moreover, bubbles hitting the channel wall on the left and right sides are found, and the motion speed of the bubbles is increased by 31.9% under the ultrasound field. Our results demonstrate that the heat transfer coefficient obtained under the ultrasound field is 53.9% higher than in the absence of the ultrasound field under the same conditions, and the enhancement ratio is decreased in the high heat flux region due to the change of the flow regime with increasing heat flux. This study provides a theoretical basis for the application of an ultrasound field in minichannel heat sinks for the enhancement of flow boiling heat transfer.

Optimization of uranium soil decontamination in alkaline washing using mechanical stirring and ultrasound field.

The ex situ decontamination of uranium polluted soils was performed by alkaline washing using mechanical agitation and ultrasound field. Two types of polluted soils were considered in terms of texture and organic content. The tests were performed using experimental design: a 23 factorial plan for mechanical washing and Taguchi L18 orthogonal matrix for ultrasound (US)-assisted decontamination. The factors considered in mechanical washing were temperature, duration, and pH. For ultrasound decontamination, the US frequency was added. The optimum was estimated based on statistical analysis and validated by confirmation experiments. The study revealed that in ultrasound field, the decontamination degree is increased with over 25% compared with mechanical stirring, while the duration of the process is drastically reduced (from 120 to 25 min). The most important factor leading to the increase of decontamination is the ultrasound frequency. To refine the result, artificial neural network modeling and subsequent optimization by genetic algorithms were also carried out for the decontamination in ultrasound field, and new optimum operating conditions were identified and validated. The best operating conditions identified were temperature around 50 °C, pH = 8, and ultrasound frequency of 24 kHz. In these conditions, the decontamination degree reached 85% for Soil 1 (characterized by low clay and organic content) and 69% for Soil 2 (with high clay and organic content).

Physical relation and mechanism of ultrasonic bactericidal activity on pathogenic E. coli with WPI.

OBJECTIVE: This study aimed to investigate the physical relation and mechanism of bactericidal activity on pathogenic E. coli by ultrasonic field with whey protein isolate (WPI). METHODS: Ultrasound treatment was performed under the conditions of intensity at 65 W/cm2, pulse duty ratio at 0.5 for 0-15 min with WPI concentration ranged from 0 to 10%. Viscosity, granularity, surface hydrophobicity, free radical scavenging activity, and thermal denaturation were assessed by rotational viscometer, Malvern Mastersizer 2000 particle size analyzer, fluorescent probe ANS method, DPPH method, and differential scanning calorimetry, respectively. RESULTS: The thermal denaturation of WPI was not altered by ultrasound field, but the viscosity of WPI was increased upon 10 min treatment. Additionally, its ability to scavenge free radicals and hydrophobicity were increased. The result also showed that the bacteria viability was improved by WPI during ultrasound treatment. However, the WPI protection was decreased by the prolonged treatment. CONCLUSION: Ultrasound treatment resulted in the increasing of the viscosity, free radicals scavenging activity and hydrophobicity of WPI which led to reduced bactericidal activity on E. coil, while WPI protection was disintegrated by prolonged treatment.

Dynamics of two interacting bubbles in a nonspherical ultrasound field.

In this paper, we present and analyze a model of the oscillations of a pair of gas bubbles driven by nonspherical ultrasound. We derived our model based on the perturbation and potential flow theories and use it to study three cases of oscillation of two bubbles under driving ultrasound with different initial phases, different separation distances between the bubbles and different sound pressure amplitudes. For the driving ultrasound with different initial phases, we obtain the in-phase and anti-phase radial pulsations of the bubbles in incompressible liquid. We also study the effect of the secondary Bjerknes force on the oscillation of bubbles separated by different relative distances. Lastly, we analyze the ratio of a nonspherical to a spherical partial quantity, and the results show that the bubbles survive longer with decreases in both the pressure amplitude of nonspherical ultrasound and the initial bubbles radii.

A Simple Technique for Visualizing Ultrasound Fields Without Schlieren Optics.

A simple technique designed for visualization of ultrasound fields without Schlieren optics is introduced. An optical system of direct shadowgraphy with diverging light, which consists of a point light source and a shadow screen, constituted the basic system, but the screen was replaced by focusing optics: a camera that makes a virtual screen at its focus plane. The proposed technique visualizes displacement of light deflected by ultrasound, and the use of focusing optics enables flexible settings of the virtual screen position and optical magnification. Insufficient sensitivity of shadowgraphy was overcome by elimination of non-deflecting light using image subtraction of shadowgrams taken with and without ultrasound exposure. A 1-MHz focused transducer for ultrasound therapy and a 20-MHz miniature transducer for intravascular imaging were used for experiments, and alternate pressure change in short-pulsed ultrasound was visualized, indicating the usefulness of the proposed technique for evaluation of medical ultrasound fields.

Washing off intensification of cotton and wool fabrics by ultrasounds.

Wet textile washing processes were set up for wool and cotton fabrics to evaluate the potential of ultrasound transducers (US) in improving dirt removal. The samples were contaminated with an emulsion of carbon soot in vegetable oil and aged for three hours in fan oven. Before washing, the fabrics were soaked for 3 min in a standard detergent solution and subsequently washed in a water bath. The dirt removal was evaluated through colorimetric measurements. The total color differences ΔE of the samples were measured with respect to an uncontaminated fabric, before and after each washing cycle. The percentage of ΔE variation obtained was calculated and correlated to the dirt removal. The results showed that the US transducers enhanced the dirt removal and temperature was the parameter most influencing the US efficiency on the cleaning process. Better results were obtained at a lower process temperature.

A role for maternal physiological state in preserving auditory cortical plasticity for salient infant calls.

A growing interest in sensory system plasticity in the natural context of motherhood has created the need to investigate how intrinsic physiological state (e.g., hormonal, motivational, etc.) interacts with sensory experience to drive adaptive cortical plasticity for behaviorally relevant stimuli. Using a maternal mouse model of auditory cortical inhibitory plasticity for ultrasonic pup calls, we examined the role of pup care versus maternal physiological state in the long-term retention of this plasticity. Very recent experience caring for pups by Early Cocarers, which are virgins, produced stronger call-evoked lateral-band inhibition in auditory cortex. However, this plasticity was absent when measured post-weaning in Cocarers, even though it was present at the same time point in Mothers, whose pup experience occurred under a maternal physiological state. A two-alternative choice phonotaxis task revealed that the same animal groups (Early Cocarers and Mothers) demonstrating stronger lateral-band inhibition also preferred pup calls over a neutral sound, a correlation consistent with the hypothesis that this inhibitory mechanism may play a mnemonic role and is engaged to process sounds that are particularly salient. Our electrophysiological data hint at a possible mechanism through which the maternal physiological state may act to preserve the cortical plasticity: selectively suppressing detrimental spontaneous activity in neurons that are responsive to calls, an effect observed only in Mothers. Taken together, the maternal physiological state during the care of pups may help maintain the memory trace of behaviorally salient infant cues within core auditory cortex, potentially ensuring a more rapid induction of future maternal behavior.